CSC TT250 - Page 106

TT250Owner’s andServiceManual
www.CSCMotorcycles.com
105

Inspectthebatteryterminalarea.Ifoxidationispresent
aroundtheterminal(itwillappearasawhitegrowtharound
theterminal),pourawater‐and‐baking‐sodasolutionover
theterminalareatoeliminatetheoxidation.Afterdoing
this,flushtheareawithwater.

Disconnectthebattery.Disconnectthe
negativeterminal
first(theonewiththegreeninsulationonthelead)andthen
disconnectthepositiveterminal.

Unhookthebattery’srubberretentionstrapandremovethe
battery.

Checktheacidlevelinthebattery.Thelevelshouldbe
betweentheupperandlowerredlinesonthefrontof
the
battery.It’salittledifficulttoseethisinthefirst
photobelow,sowetiltedthebatterysoyoucanseeitbetter.

Ifanyofthecellsarebelowtheminimumlevel,removethe
fillercapforeachaffectedcell.Addonlydistilledwatertoa
cellifitisbelowtheminimumlevelsuchthatthecelllevelis
withintheacceptablerange.