CSC TT250 - Inspections Before Riding

TT250Owner’s andServiceManual
www.CSCMotorcycles.com
6

InspectionsBeforeRiding

Beforeridingyourmotorcycle,youshouldcheckthefollowing:

 Bothtiresareappropriatelyinflated.

 Neithertirehasnailsnorotherforeignobjectsembeddedinthetreadorthesidewall.

 Thefueltankcontainsadequatefuel,andthefuelpetcockisintheON
position.Ifthefuel
petcockisintheRESERVEposition,fillthefueltankatthenextopportunity.

 Thecrankcasehasoil.Youcanchecktheoillevelusingeitherthedipstickorthecrankcase
viewingport.

 Theturnsignals,thefrontandrearbrakelights,thehorn,
andtheheadlightalloperatewhen
commandedtodoso(theignitionswitchmustbeintheONposition).

 Thefrontandrearbrakelevershaveadequatefreeplay.

 Thefrontandrearbrakesoperate.

 Theforksturnfreelyfromsidetoside.

 The
rearviewmirrorsareadjustedappropriately.

 TheenginekillswitchisintheRUNposition.

 Thechainhasappropriateslack.

 Majorthreadedfastenersaretight.Wealwayshandchecktheaxlenuts,theexhaustheader
nutsandbolts,themufflerboltsandnuts(grabthemuffler
andcheckitforanyside‐to‐side
play),thesteeringstemnut,andthefrontandrearcaliperbolts.

MotorcycleSpecifications

General
Type Dualsport
Designation CSCTT Special
Colors Copper,black,white
Fuel 87octane
FuelCapacity 2.9gallons
TopSpeed Dependentongearingandriderweight;approximately70mphwith17T
countershaftsprocketand50Trearsprocket.Othergearratiosavailable
fromCSC.
Powertrain
EngineConfiguration Singlecylinder,aircooled,2valve,carbureted,counterbalanced,choke