Section 2 - Care and Safety
Safety Notices
Safety Checklist
2-10 2-10
9803/9390-2
!MWARNING
Accumulators
The accumulators contain hydraulic fluid and gas at
high pressure. Prior to any work being carried out on
systems incorporating accumulators, the system
pressure must be exhausted by a JCB distributor, as
the sudden release of the hydraulic fluid or gas may
cause injury.
INT-3-1-17
!MWARNING
An exploding tyre can kill. Inflated tyres can explode if
over-heated or over-inflated. Follow the instructions
given when inflating the tyres. Do not cut or weld the
rims. Use a tyre/wheel specialist for all repair work.
2-3-2-7_2
!MWARNING
Jacking
A machine can roll off jacks and crush you unless the
wheels have been chocked. Always chock the wheels
at the opposite end of the machine that is to be jacked.
Do not work underneath a machine supported only by
jacks. Always support a jacked-up machine on axle
stands before working underneath it.
INT-3-2-8
!MWARNING
Under no circumstances must the engine be run with
the transmission in gear and only one driving wheel
jacked clear of the ground, since the wheel on the
ground will move the machine.
INT-3-1-16
!MWARNING
Wheels and tyres are heavy. Take care when lifting or
moving them.
Store with care to ensure that they cannot fall and
cause injury.
13-3-1-7_1
!MWARNING
Asbestos
Asbestos dust can damage your lungs. Some engine
gaskets contain asbestos. Do not dismantle the
engine or exhaust system; get these jobs done by a
qualified person who has a copy of the engine service
manual.
5-1-6-1
To Next Page
Loading...