9 SERVICE SCHEDULE 59
9.1 Service schedule
Every 20,000 km (12,428 mi) or every 2 years
Every 10,000 km (6,214 mi) or annually or after every sporting use
Once after 1,000 km (621.4 mi)
Check that the electrical equipment is functioning correctly. ○ ● ●
Read out the fault memory using the KTM diagnostics tool. x
○ ● ●
Check the measured service values with the KTM diagnostics tool. x
● ●
Change the engine oil and filter, clean the oil screens. x ( p. 143)
○ ● ●
Check the front brake linings. ( p. 93) ○ ● ●
Check the rear brake linings. ( p. 98) ○ ● ●
Check the brake discs. ( p. 90) ○ ● ●
Check the brake lines for damage and leakage. ○ ● ●
Check the rear brake fluid level. ( p. 96) ○ ● ●
Check the free travel of the foot brake lever. ( p. 94) ○ ● ●
Check that the shock absorber and fork are leak tight. If necessary and depending on use, service the fork and shock
absorber.
○ ● ●
Check the swingarm bearing. x
● ●
Check the wheel bearing for play. x
● ●
Check the tire condition. ( p. 108) ○ ● ●
Check the tire air pressure. ( p. 110) ○ ● ●
Check the spoke tension. ( p. 111) ○ ● ●
Check for rim run-out. x
○ ● ●
Check the chain, rear sprocket, engine sprocket, and chain guide. ( p. 82) ● ●
Check the chain tension. ( p. 79) ○ ● ●