KTM Freeride E-SX - Riding Instructions and Procedures; Pre-Ride Checks and Maintenance; Starting the Motorcycle

128 pages

Save Page as PDF

To Next Page

To Previous Page

7 DISPLAY 33

Press the right but-

ton briefly.

Next display mode

Press the right but-

ton for 3 – 5 sec-

onds.

AVG is reset to 0.0.

Main Page

Default Chapter4
- Table of Contents4
1 Means of Representation7
- Symbols Used7
- Formats Used7
2 Safety Advice8
- Use Definition - Intended Use8
- Degrees of Risk and Symbols8
- Safety Instructions and Warning Labels (Freeride E-SX)9
- Safety Instructions and Warning Labels (Freeride E-XC)12
- Tampering Warning14
- Safe Operation14
- Fall or Accident15
- Protective Clothing15
- Work on the Vehicle, Motor, and Lithium-Ion Battery (KTM Powerpack)15
- Environment15
- Owner's Manual16
- Fire Hazard16
3 Important Notes17
- Guarantee, Warranty17
- Operating and Auxiliary Substances17
- Spare Parts, Accessories17
- Service17
- Figures17
- Customer Service17
- System Voltage18
- New KTM Powerpack18
- Operation at Low Temperatures18
4 View of Vehicle19
- View of Vehicle, Front Left (Example) (Freeride E-SX)19
- View of Vehicle, Rear Right (Example) (Freeride E-SX)20
- View of Vehicle, Front Left (Example) (Freeride E-XC)21
- View of Vehicle, Rear Right (Example) (Freeride E-XC)22
5 Serial Numbers23
- Chassis Number23
- Type Label23
- Motor Number23
- Fork Part Number23
- Shock Absorber Part Number23
- Battery Identification Number24
6 Controls25
- Front Brake Lever25
- Rear Brake Lever25
- Throttle Grip25
- Main Switch25
- Start Button26
- Horn Button (Freeride E-XC)26
- Light Switch (Freeride E-XC)26
- Turn Signal Switch (Freeride E-XC)26
- Side Stand27
- Ignition Lock (Freeride E-XC)27
- Steering Lock (Freeride E-XC)27
- Locking the Steering (Freeride E-XC)28
- Unlocking the Steering (Freeride E-XC)28
7 Display29
- Multifunction Display29
- Map-Select Tip Switch29
- Driving Mode Display29
- Electric Motor Indicator Lamp (MIL)30
- Charge Level Indicator30
- Power Reduction30
- Speedometer (Freeride E-XC)31
- Overview31
- Activation31
- Message on the Speedometer31
- Setting the Speedometer31
- Setting Kilometers or Miles32
- Setting the Clock33
- Setting the Service Display33
- Speed, Time, and DST Distance 134
- Speed, Time, and DST2 Distance 234
- AVG Average Speed, ART Operating Hours, and ODO Total Distance Covered34
8 Preparing for Use36
- Advice on First Use36
9 Riding Instructions37
- Checks and Maintenance Work When Preparing for Use37
- Starting37
- Starting off38
- Applying the Brakes38
- Stopping, Parking39
- Deactivating the Vehicle39
- Transporting the Vehicle40
- Transporting the KTM Powerpack40
10 Service Schedule41
- Service Work (as Additional Order)42
11 Tuning the Chassis43
- Checking the Basic Chassis Setting with the Rider's Weight43
- Compression Damping of the Shock Absorber43
- Adjusting the Low-Speed Compression Damping of the Shock Absorber43
- Adjusting the High-Speed Compression Damping of the Shock Absorber44
- Adjusting the Rebound Damping of the Shock Absorber45
- Measuring Rear Wheel Sag Unloaded45
- Checking the Static Sag of the Shock Absorber46
- Checking the Riding Sag of the Shock Absorber46
- Adjusting the Spring Preload of the Shock Absorber46
- Adjusting the Riding Sag47
- Checking the Basic Setting of the Fork48
- Adjusting the Compression Damping of the Fork48
- Adjusting the Rebound Damping of the Fork49
- Handlebar Position49
- Adjusting the Handlebar Position49
12 Service Work on the Chassis51
- Raising the Motorcycle with the Lift Stand51
- Removing the Motorcycle from the Lift Stand51
- Bleeding the Fork Legs51
- Cleaning the Dust Boots of the Fork Legs52
- Removing the Fork Legs52
- Installing the Fork Legs53
- Removing the Fork Protector55
- Installing the Fork Protector55
- Removing the Lower Triple Clamp56
- Installing the Lower Triple Clamp57
- Checking the Play of the Steering Head61
- Adjusting the Play of the Steering Head Bearing61
- Greasing the Steering Head Bearing62
- Removing the Start Number Plate (Freeride E-SX)62
- Installing the Start Number Plate (Freeride E-SX)63
- Removing the Front Fender63
- Installing the Front Fender63
- Removing the Shock Absorber64
- Installing the Shock Absorber64
- Folding the Seat up65
- Locking the Seat65
- Removing the Spoiler65
- Installing the Spoiler66
- Mounting the Covering Cap66
- Removing the Covering Cap67
- Checking the Battery Discharge Plug Form Ring67
- Checking for Chain Dirt Accumulation67
- Cleaning the Chain67
- Checking the Chain Tension68
- Adjusting the Chain Tension69
- Checking the Chain, Rear Sprocket, Motor Sprocket, and Chain Guide70
- Checking the Frame71
- Checking the Swingarm72
- Checking the Rubber Grip72
- Additionally Securing the Rubber Grip72
13 Brake System73
- Checking the Free Travel of the Front Brake Lever73
- Adjusting the Basic Position of the Front Brake Lever (Freeride E-SX)73
- Adjusting the Free Travel of the Front Brake Lever (Freeride E-XC)73
- Checking the Brake Discs74
- Checking the Brake Fluid Level of the Front Brake74
- Adding Front Brake Fluid75
- Checking the Front Brake Linings76
- Changing the Front Brake Linings76
- Checking the Free Travel of the Rear Brake Lever78
- Adjusting the Basic Position of the Rear Brake Lever (Freeride E-SX)78
- Adjusting the Free Travel of the Rear Brake Lever (Freeride E-XC)79
- Checking the Rear Brake Fluid Level79
- Adding Rear Brake Fluid79
- Checking the Rear Brake Linings80
- Changing the Rear Brake Linings81
14 Wheels, Tires83
- Removing the Front Wheel83
- Installing the Front Wheel83
- Removing the Rear Wheel84
- Installing the Rear Wheel85
- Checking the Tire Condition86
- Checking the Tire Air Pressure86
- Checking the Spoke Tension87
15 Electrical System88
- Removing the 12 V Battery88
- Installing the 12 V Battery88
- Recharging the 12 V Battery89
- Changing the Fuses of Individual Power Consumers90
- Removing the Headlight Mask with the Headlight (Freeride E-XC)91
- Refitting the Headlight Mask with the Headlight (Freeride E-XC)92
- Changing the Headlight Bulb (Freeride E-XC)92
- Changing the Turn Signal Bulb (Freeride E-XC)93
- Checking the Headlight Setting (Freeride E-XC)94
- Adjusting the Headlight Range (Freeride E-XC)94
- Changing the Speedometer Battery (Freeride E-XC)94
16 Ktm Powerpack, Battery Charger96
- Removing the KTM Powerpack96
- Installing the KTM Powerpack96
- Overview of the KTM Powerpack Battery Charger97
- Positioning the Battery Charger98
- Recharging the KTM Powerpack98
- Charging the KTM Powerpack in the Storage Charging Mode100
17 Cooling System103
- Checking the Antifreeze and Coolant Level103
- Checking the Coolant Level104
- Draining the Coolant104
- Refilling with Coolant105
18 Tuning the Motor106
- Selecting the Driving Mode106
19 Service Work on the Motor107
- Changing the Gear Oil107
20 Cleaning, Care109
- Cleaning the Motorcycle109
- Checks and Maintenance Steps for Winter Operation (Freeride E-XC)110
- Operation (Freeride E‑XC)110
21 Storage111
- Preparing for Use after Storage111
22 Troubleshooting112
- Vehicle Troubleshooting112
- Troubleshooting of the Battery Charger114
- Troubleshooting of the KTM Powerpack When Connected to the Battery Charger115
23 Technical Data116
- Motor116
- Motor Tightening Torques116
- Capacities116
- Gear Oil116
- Coolant116
- Chassis116
- Electrical System117
- Tires117
- Fork118
- Shock Absorber118
- Chassis Tightening Torques119
24 Substances120
25 Auxiliary Substances121
26 Standards122
- Index123
- General Information128

KTM Freeride E-SX - Riding Instructions and Procedures; Pre-Ride Checks and Maintenance; Starting the Motorcycle

Table of Contents

Related product manuals