10 SERVICE SCHEDULE 39
10.1 Service schedule
Every 50 operating hours
Every 20 operating hours after sporting use
Once after 1 operating hour
Read out the fault memory using the KTM diagnostics tool. ○ ● ●
Check that the electrical equipment is functioning properly. (Freeride E‑XC) ○ ● ●
Check and charge the 12 V battery. ● ●
Check and recharge the KTM PowerPack. ○ ● ●
Check the front brake linings. ( p. 74) ● ●
Check the rear brake linings. ( p. 78) ● ●
Check the brake discs. ( p. 72) ● ●
Check the brake lines for damage and leakage. ● ●
Check the frame and swingarm. ● ●
Check the heim joints at the top and bottom of the shock absorber. ● ●
Check the tire condition. ( p. 84) ○ ● ●
Check the tire air pressure. ( p. 84) ○ ● ●
Check the wheel bearing for play. ● ●
Check the wheel hubs. ● ●
Check the rim run-out. ○ ● ●
Check the spoke tension. ( p. 85) ○ ● ●
Check the chain, rear sprocket, motor sprocket, and chain guide. ( p. 68) ● ●
Check the chain tension. ( p. 66) ○ ● ●
Grease all moving parts (e.g., side stand, hand lever, chain, ...) and check for smooth operation. ○ ● ●
Check the front brake fluid level. ( p. 72) ● ●
Check the rear brake fluid level. ( p. 77) ● ●
Check the travel of the brake levers. ● ●
Check the play of the steering head. ( p. 59) ○ ● ●
Check all hoses and bellows for cracking, leaks and incorrect routing. ○ ● ●
Check the antifreeze and coolant level. ( p. 101) ○ ● ●
Check the cables for damage and routing without sharp bends. ● ●
Check the battery discharge plug form ring for damage. ○ ● ●
Check the screws and nuts for tightness. ○ ● ●
Check the screw connections on the KTM PowerPack for the specified tightening torque. ○ ● ●
Check the headlight setting. (Freeride E‑XC) ( p. 92) ○ ● ●
Final check: Check the vehicle for safe operation and take a test ride. (Freeride E‑SX) ○ ● ●
Final check: Check the vehicle for roadworthiness and take a test ride. (Freeride E‑XC) ○ ● ●
Read out the error memory after the test ride using the KTM diagnostics tool. ○ ● ●
Make the service entry in the KTM Dealer.net and in the Service and Warranty Booklet. ○ ● ●
○ One-time interval
● Periodic interval
To Next Page
Loading...
