Lenovo thinksystem SR630 - default chapter; Table of Contents

Contents
Safety . . . . . . . . . . . . . . . . . . v
Safety inspection checklist . . . . . . . . . . . vi
Chapter 1. Introduction . . . . . . . . . 1
Specifications . . . . . . . . . . . . . . . . 2
Particulate contamination . . . . . . . . . 10
Firmware updates . . . . . . . . . . . . . . 11
Tech Tips . . . . . . . . . . . . . . . . . 15
Security advisories . . . . . . . . . . . . . 16
Power on the server . . . . . . . . . . . . . 16
Power off the server . . . . . . . . . . . . . 16
Chapter 2. Server components . . . . 19
Front view . . . . . . . . . . . . . . . . . 19
Diagnostics panel . . . . . . . . . . . . 26
LCD diagnostics panel . . . . . . . . . . 28
External LCD diagnostics handset. . . . . . 33
Rear view . . . . . . . . . . . . . . . . . 39
Rear view LEDs . . . . . . . . . . . . . 43
System board components . . . . . . . . . . 44
System board LEDs . . . . . . . . . . . 46
Switch block . . . . . . . . . . . . . . 48
Parts list. . . . . . . . . . . . . . . . . . 49
Power cords . . . . . . . . . . . . . . 52
Chapter 3. Internal cable routing . . . 55
CFF HBA/RAID adapter. . . . . . . . . . . . 57
Front I/O . . . . . . . . . . . . . . . . . 58
Intrusion switch . . . . . . . . . . . . . . . 59
RAID super capacitor modules . . . . . . . . . 60
M.2 drive backplane . . . . . . . . . . . . . 62
16-EDSFF drive backplane . . . . . . . . . . 63
7mm drive backplane . . . . . . . . . . . . 64
2.5-inch/3.5-inch drive backplane (power) . . . . 65
2.5-inch/3.5-inch drive backplane (signal). . . . . 66
4 x 3.5-inch front drive bays . . . . . . . . 66
4 x 2.5-inch front drive bays . . . . . . . . 70
8 x 2.5-inch front drive bays . . . . . . . . 73
10 x 2.5-inch front drive bays. . . . . . . . 78
Chapter 4. Hardware replacement
procedures . . . . . . . . . . . . . . . 83
Installation guidelines . . . . . . . . . . . . 83
Safety inspection checklist. . . . . . . . . 84
System reliability guidelines . . . . . . . . 85
Working inside the server with the power on . . 85
Handling static-sensitive devices . . . . . . 85
Technical rules . . . . . . . . . . . . . . . 86
Technical rules for processors and heat
sinks . . . . . . . . . . . . . . . . . 86
Technical rules for drives . . . . . . . . . 87
Technical rules for RAID configuration . . . . 87
Technical rules for PCIe adapters . . . . . . 88
Technical rules for GPU adapters . . . . . . 89
Technical rules for system fans . . . . . . . 90
Air baffle replacement . . . . . . . . . . . . 91
Remove the air baffle . . . . . . . . . . . 91
Install the air baffle . . . . . . . . . . . . 92
Backplane replacement. . . . . . . . . . . . 94
Remove the front 2.5-inch drive backplane . . 94
Install the front 2.5-inch drive backplane . . . 95
Remove the front 3.5-inch drive backplane . . 96
Install the front 3.5-inch drive backplane . . . 97
Remove the front 16-EDSFF drive
backplane . . . . . . . . . . . . . . . 99
Install the front 16-EDSFF drive backplane . . 100
Remove the 2.5-inch rear drive backplane. . . 101
Install the 2.5-inch rear drive backplane . . . 103
Remove the 7mm drive backplanes . . . . . 105
Install the 7mm drive backplanes . . . . . . 107
CMOS battery replacement . . . . . . . . . . 108
Remove the CMOS battery . . . . . . . . 108
Install the CMOS battery . . . . . . . . . 110
EDSFF cage replacement . . . . . . . . . . . 112
Remove an EDSFF cage . . . . . . . . . 112
Install an EDSFF cage . . . . . . . . . . 113
Front I/O assembly replacement . . . . . . . . 115
Remove the front I/O assembly . . . . . . . 116
Install the front I/O assembly . . . . . . . . 117
Remove the LCD diagnostics panel
assembly . . . . . . . . . . . . . . . 118
Install the LCD diagnostics panel
assembly . . . . . . . . . . . . . . . 119
Heat sink Torx T30 nut replacement . . . . . . . 121
Remove a heat sink Torx T30 nut . . . . . . 121
Install a heat sink Torx T30 nut . . . . . . . 122
Hot-swap drive replacement . . . . . . . . . . 123
Remove a 2.5/3.5-inch hot-swap drive . . . . 124
Install a 2.5/3.5-inch hot-swap drive . . . . . 125
Remove an EDSFF drive . . . . . . . . . 126
Install an EDSFF drive . . . . . . . . . . 128
Hot-swap power supply unit replacement . . . . 130
Remove a hot-swap power supply unit . . . . 130
Install a hot-swap power supply . . . . . . 135
© Copyright Lenovo 2021 i