Index
A
Acceleration Is Poor or Throttle Response Is
Poor .................................................................65
Probable Causes .............................................65
Recommended Actions ....................................65
Aftertreatment Identification Module - Test........... 268
Alternator Problem (Charging Problem and/or
Noisy Operation) ...............................................73
Probable Causes .............................................73
Recommended Actions ....................................73
B
Battery Problem ..................................................75
Probable Causes .............................................75
Recommended Actions ....................................75
Belt Tensioner Noise ...........................................76
Probable Causes .............................................76
Recommended Actions ....................................76
C
CAN Data Link - Test ......................................... 271
Circuit Tests...................................................... 268
Clean Emissions Module Has High Oxygen
Level ................................................................81
Codes that Inhibit Operation of Aftertreatment
System ........................................................... 505
Diagnostic Trouble Codes that Affect the
Aftertreatment System and the Conditions for
Clearing the Code ........................................ 505
Component Location ...........................................12
Electronic Control Circuit Diagram.....................12
Sensor Locations.............................................16
Configuration Parameters ....................................29
Check Programmable Parameters (630-2/268-
2)..................................................................31
Coolant Contains Oil ...........................................82
Probable Causes .............................................82
Recommended Actions ....................................82
Coolant Level - Test........................................... 276
Coolant Level Is Low ...........................................84
Probable Causes .............................................85
Recommended Actions ....................................85
Coolant Temperature Is High................................85
Probable Causes .............................................86
Recommended Actions ....................................86
Coolant Temperature Is Low ................................89
Probable Causes .............................................89
Recommended Actions ....................................89
Cooling Fan Control - Test (Hydraulic Driven
Fan) ...............................................................278
Cooling Fan Control - Test (Viscous Clutch Fan
) ..................................................................... 281
Cooling Fan Speed - Test................................... 283
Crankcase Breather Ejects Oil .............................91
Probable Causes .............................................91
Recommended Actions ....................................91
Crankcase Fumes Disposal Tube Has Oil
Draining............................................................92
Probable Causes .............................................92
Recommended Actions ....................................92
Customer Passwords ........................................499
Cylinder Is Noisy .................................................95
Probable Causes .............................................95
Recommended Actions ....................................95
D
Data Link - Test ................................................. 285
Data Link Configuration Status - Test .................. 293
DEF Concentration Is Incorrect ............................98
DEF Control Module Power - Test.......................296
DEF Line Heater - Test ...................................... 299
DEF Pressure Does Not Respond ......................101
DEF Pressure Is High ........................................ 103
DEF Pressure Is Low......................................... 107
DEF Pump - Test...............................................304
DEF Pump Pressure Sensor - Test ..................... 307
DEF Pump Sensor Supply - Test ........................ 309
DEF Tank Level Is Low ...................................... 112
DEF Tank Sensor - Test ..................................... 311
DEF Tank Temperature Is High........................... 115
DEF Tank Temperature Is Low ........................... 118
Diagnostic Capabilities ........................................23
Diagnostic Codes.............................................23
Diagnostic Trouble Codes....................................32
Diagnostic Trouble Codes in J1939 Order..........32
Diagnostic Trouble Codes in Perkins Data Link
(PDL) Code Order ..........................................42
Diesel Oxidation Catalyst Has Incorrect Inlet
Temperature ................................................... 121
Diesel Oxidation Catalyst Has Low Conversion
Efficiency ........................................................ 124
Diesel Particulate Filter Collects Excessive
Soot (If Equipped)............................................ 125
Diesel Particulate Filter Regeneration ...................22
Regeneration...................................................22
Selective Catalyst Reduction (SCR) ..................22
Diesel Particulate Filter Temperature Is Low (If
Equipped) ....................................................... 130
E
ECM - Replace ................................................. 510
Engine ECM .................................................. 510
ECM Software - Install ....................................... 508
Flash Programming a Flash File......................508
ECM Software - Install (Dosing Control Unit
(DCU))............................................................ 509
Flash Programming a Flash File......................509
Flash Programming a Reset File ..................... 509
ECM Will Not Accept Factory Passwords ............500
Probable Causes ........................................... 500
Recommended Actions .................................. 500
Electrical Connectors ..........................................24
Connectors for the Electronic Control Module
(ECM) ...........................................................24
Connectors on the Pump and Electronics Unit
(PEU)............................................................26
Injector Connectors..........................................27
Sensor Connectors ..........................................27
Electrical Connectors - Inspect ........................... 511
Electrical Power Supply - Test ............................ 314
Electronic Service Tool Does Not Communicate ..500
Electronic Service Tools.........................................7
UENR4469-36 521
Index Section
Copyright of Perkins Engine Company Limited. NOT FOR REPRINTING OR RESALE
To Next Page
Loading...
