Appendixes
Appendixes
Appendix B
Page 6
Suggested Torque Values (critical hardware)
Torque Table
Torque Range
Group Description Ft-Lbs In-Lbs Nm
Brakes - - - - - - - - - - - - - - - - - - - - - - - -
Brake bolt (disc brake body) 11 - 11 132 - 132 15 - 15
Brake line tube nut fittings 12 - 13 144 - 156 16.3 - 17.7
Brake spider bolts (Dana 160mm hyd brakes) 25 - 35 300 - 420 34 - 47.6
Brake spider bolts (Dana 160mm mech brakes) 15 - 19 180 - 228 20.4 - 25.8
Brake spider bolts (Dana 7x1-3/4 brakes) 16 - 20 192 - 240 21.8 - 27.2
Electrical - - - - - - - - - - - - - - - - - - - - - - - -
Battery terminals 8 - 9 96 - 108 10.9 - 12.2
Front Axle - - - - - - - - - - - - - - - - - - - - - - - -
Front spindle nut - - -
Note: Refer to maintenance section in the service manual
King pin - - -
Note: Refer to maintenance section in the service manual
Rear Axle/Transmission - - - - - - - - - - - - - - - - - - - - - - - -
3rd member Gear case cover (GT drive) 45 - 50 540 - 600 61.2 - 68
Axle bolt (GT drive) 275 - 275 3300 - 3300 374 - 374
Axle hub nut (Dana) 95 - 115 1140 - 1380 129.2 - 156.4
Axle tube to center section (Dana F-N-R) 25 - 35 300 - 420 34 - 47.6
Carrier cap bolts (Dana) 100 - 120 1200 - 1440 136 - 163.2
Differential Cover plate (Dana H12) 18 - 25 216 - 300 24.5 - 34
Drain plug (Dana H12) 25 - 40 300 - 480 34 - 54.4
Drain plug (GT drive) 21 - 25 252 - 300 28.6 - 34
Gear case to 3rd member (GT drive) 18 - 20 216 - 240 24.5 - 27.2
Motor mounting (GT/Dana) 6.5 - 7 78 - 84 8.8 - 9.5
Pinion nut (F2/F3) 175 - 175 2100 - 2100 238 - 238
Pinion nut (GT drive) 154 - 169 1848 - 2028 209.4 - 229.8
Ring gear (Dana) 35 - 45 420 - 540 47.6 - 61.2
Wheel lug nut 75 - 90 900 - 1080 102 - 122.4
Steering - - - - - - - - - - - - - - - - - - - - - - - -
Ball joint clamp 28 - 32 336 - 384 38.1 - 43.5
Ball joint nut 40 - 45 480 - 540 54.4 - 61.2
Pitman nut (18-308-21 steering gear) 75 - 100 900 - 1200 102 - 136
Pitman nut (18-308-25 steering gear) 181 - 217 2172 - 2604 246.2 - 295.1
Rod end nut 20 - 25 240 - 300 27.2 - 34
Steering shaft pinch bolt 24 - 26 288 - 312 32.6 - 35.4
Steering wheel nut (18-308-21 steering gear) 28 - 32 336 - 384 38.1 - 43.5
Steering wheel nut (18-308-25 steering gear) 72 - 86 864 - 1032 97.9 - 117
Suspension - - - - - - - - - - - - - - - - - - - - - - - -
Leaf spring hangers - - -
Note: Refer to maintenance section in the service manual
To Next Page