Maintenance, Service and Repair
Maintenance Page 4
TROUBLESHOOTING GUIDE
Symptom Probable Cause
Steering Pulls in One Direction
Front End Out of Alignment
Low Tire Pressure
Hard Steering
Dry Lube Points in Steering Linkage
Damaged King Pin/Ball Joint
Low Tire Pressure
Excessive Steering Play
Worn Ball Joints
Mis-Adjusted or Worn Steering Gear
Loose Steering Linkage
Lack of Power or Slow Operation
Brakes or Parking Brakes Dragging
Worn Drive Gears
Front End Out of Alignment
Defective Speed Control
Abnormal Noise
Worn Drive Gears or Bearings
Worn Front /Rear Axle Bearings
Loose Lug Nuts
Motor Bearings Worn
Oil Leak in Rear Bearing Area
Rear Wheel Bearing and/or Gasket Failed
Drive Over Filled
Brake Pedal Soft or Spongy Air in Brake Lines
Brake Pedal Low
Brake Worn (1/16" Wear Limit)
Brake Fluid Low
Brakes Out of Adjustment
Braking Power Low
Brake Worn (1/16" Wear Limit)
Brake Pads Contaminated with Fluid
Brake Pedal Linkage Binding
Brakes Out of Adjustment
Air in Brake Lines
To Next Page
Loading...
