2-2
INSP
ADJ
PERIODIC MAINTENANCE TABLE
Item Remarks
Pre-
operation
check
(daily)
Initial
1 month
or
first 800 km
(500 mi)
(40 hr)
Every
Seasonally
or
3,200 km
(2,000 mi)
(160 hr)
Whenever operating elevation is changed
Whenever operating elevation is changed
Every 1,600
km (1,000 mi)
Slide runner
Brake/parking brake
Disk brake installation
Drive chain oil
Drive chain
Ski/ski runner
Steering system
Lights
Primary sheave
Secondary sheave
Steering column bearing
Ski and front suspension
Suspension component
Parking brake cable end
and lever end/throttle
cable end
Shroud latches
Fittings/fasteners
Service tools/spare parts
Check for wear and damage.
Replace if necessary.
Check operation and fluid leakage.
Adjust free play and/or replace pads if necessary.
Change brake fluid.
Check for slight free play.
Lubricate shaft with specified grease as required.
Check oil level.
Change.
Check deflection.
Adjust if necessary.
Check for wear and damage.
Replace if necessary.
Check operation.
Adjust toe-out if necessary.
Check operation. Replace bulbs if necessary.
Check engagement and shift speed.
Adjust if necessary.
Check for wear and damage. Replace if necessary.
Lubricate with specified grease.
Lubricate with specified grease.
Adjust if necessary.
Lubricate with specified grease.
Lubricate with specified grease.
Lubricate with specified grease.
Lubricate with specified grease.
Check cable damage. Replace if necessary.
Make sure the shroud latches are hooked.
Check tightness. Repair if necessary.
Check for proper placement.
See NOTE.
After the first 80 km (50 mi) and every 800 km
(500 mi) thereafter
NOTE:
Brake fluid replacement:
1. When disassembling the master cylinder or caliper, replace the brake fluid. Regularly check the brake
fluid level and add fluid as required.
2. On the inner parts of the master cylinder and caliper, replace the oil seals every two years.
3. Replace the brake hoses every four years, or if cracked or damaged.
2
To Next Page
Loading...
