Fischer Panda 10000i - Page 6

Seite/Page 6 Inhalt/Contens 16.1.15
Inhalt / Contens
5.19.1 Configuration of the electronic fan control PKD T5 for Fischer Panda Generators ........ .. 102
5.20 Exhaust installation ......................................................................................................................... .. 103
5.21 Isolation test.................................................................................................................................... .. 103
5.22 Set into operation............................................................................................................................ .. 104
5.23 ........................................................................................................................................................ .. 104
6 Generator operation instruction ............................................................................................................ ... 105
6.1 Personal requirements.................................................................................................................... .. 105
6.2 Hazard notes for the operation ....................................................................................................... .. 105
6.3 General operating instruction.......................................................................................................... .. 105
6.3.1 Operation at low temperatures ....................................................................................... .. 105
6.3.1.1 Pre-heating the diesel motor ............................................................................ .. 106
6.3.1.2 Tips regarding starter battery ........................................................................... .. 106
6.3.2 Light load operation and engine idle ............................................................................... .. 106
6.3.2.1 The soot of the generator is due to the fact that:.............................................. .. 106
6.3.2.2 To prevent the soot of the generator following steps should be observed: ...... .. 106
6.3.3 Generator load for a longer period and overload ............................................................ .. 106
6.3.4 Protection conductor: ...................................................................................................... .. 107
6.3.5 Operating control system on the Fischer Panda generator ............................................ .. 107
6.4 Instructions for capacitors - not present at all models..................................................................... .. 107
6.5 Checks before start - see remote control panel data sheet ............................................................ .. 107
6.6 Starting the generator - see remote control panel data sheet......................................................... .. 108
6.7 Stopping the generator - see remote control panel data sheet....................................................... .. 108
7 Maintenance Instructions....................................................................................................................... ... 109
7.1 Personal requirements.................................................................................................................... .. 109
7.2 Hazard notes for the maintenance.................................................................................................. .. 109
7.3 Environmental protection ................................................................................................................ .. 111
7.4 Maintenance Requirements ............................................................................................................ .. 111
7.5 Maintenance interval....................................................................................................................... .. 111
7.6 Checking oil-level............................................................................................................................ .. 111
7.6.1 Refilling Oil ...................................................................................................................... .. 113
7.6.2 After the oil level check and refilling the oil ..................................................................... .. 113
7.7 Replacement of engine oil and engine oil filter ............................................................................... .. 113
7.7.1 After the oil change ......................................................................................................... .. 116
7.8 Verifying the starter battery and (if necessary) the battery bank..................................................... .. 116
7.8.1 Battery ............................................................................................................................ .. 116
7.8.1.1 Check battery and cable connections .............................................................. .. 116
7.8.1.2 Check electrolyte level ..................................................................................... .. 117
7.8.1.3 Check electrolyte density ................................................................................. .. 117
7.9 Ventilating the fuel system.............................................................................................................. .. 118
7.9.1 Replacement of the fuel filter .......................................................................................... .. 119
7.9.1.1 Optional fuel filter with sight glass .................................................................... .. 119
7.10 RReplacing the Air Filter ................................................................................................................. .. 120
7.10.1 Ventilation of the coolant circuit / freshwater .................................................................. .. 121
7.10.2 ........................................................................................................................................ .. 124
7.11 V-belt replacement for the internal cooling water pump.................................................................. .. 124