KAESER M 64 - Page 12

Tab. 55 Delivery in generator mode ........................................................................................................ 21
Tab. 56 Connection sockets .................................................................................................................... 21
Tab. 57 Circuit breaker ............................................................................................................................ 22
Tab. 58 Generator operating limits .......................................................................................................... 22
Tab. 59 Maximum power supply load ...................................................................................................... 22
Tab. 60 Power reduction at elevated ambient temperatures ................................................................... 22
Tab. 61 Inspection intervals according to Ordinance on Industrial Safety and Health ............................ 25
Tab. 62 Danger areas .............................................................................................................................. 33
Tab. 63 Safety signs ................................................................................................................................ 34
Tab. 64 Generator / Compressor operation ............................................................................................. 52
Tab. 65 Generator operating modes ....................................................................................................... 52
Tab. 66 Stationary machines ................................................................................................................... 56
Tab. 67 Measures for re-commissioning the compressor after a long period of storage or de-
commissioning
............................................................................................................................
61
Tab. 68 Positioning and operating conditions checklist ........................................................................... 61
Tab. 69 Low-temperature equipment checklist ........................................................................................ 65
Tab. 70 Test instructions for a generator with an earth leak detection device. ....................................... 68
Tab. 71 Fault: engine refuses to start or comes to a stop. ...................................................................... 83
Tab. 72 Alarm: "engine does not reach full speed". ................................................................................ 84
Tab. 73 Alarm: "Control lamp remains on" .............................................................................................. 84
Tab. 74 "Motor running backwards" fault ................................................................................................. 85
Tab. 75 Fault: working pressure too high ................................................................................................ 85
Tab. 76 Fault: working pressure too low .................................................................................................. 85
Tab. 77 Fault: pressure relief valve blowing off ....................................................................................... 86
Tab. 78 Fault: machine overheating ........................................................................................................ 86
Tab. 79 Alarm: "Too much oil residue in the compressed air" ................................................................. 87
Tab. 80 Alarm: "Oil flows from the compressor air filter after shutdown" ................................................ 87
Tab. 81 Fault: high moisture content in the compressed air .................................................................... 88
Tab. 82 Faults in the diesel particulate filter ............................................................................................ 88
Tab. 83 Fault 'blue engine exhaust' ......................................................................................................... 88
Tab. 84 Grey or brownish exhaust gas .................................................................................................... 89
Tab. 85 There is no voltage or too low a voltage from the generator ...................................................... 89
Tab. 86 Generator voltage too high ......................................................................................................... 89
Tab. 87 Advise others that the machine is being serviced. ..................................................................... 91
Tab. 88 Maintenance tasks after commissioning .................................................................................... 93
Tab. 89 Maintenance intervals and regular maintenance tasks .............................................................. 93
Tab. 90 Regular machine maintenance tasks ......................................................................................... 94
Tab. 91 Regular maintenance task options ............................................................................................. 96
Tab. 92 KAESER coolant mixture table ................................................................................................... 100
Tab. 93 Dimensions of the flexible pipe connection ................................................................................ 136
Tab. 94 Belt tension values ..................................................................................................................... 156
Tab. 95 Maintenance log ......................................................................................................................... 161
Tab. 96 Compressor consumables .......................................................................................................... 162
Tab. 97 Consumable engine parts .......................................................................................................... 162
Tab. 98 Replacement parts, combination filter ........................................................................................ 163
Tab. 99 Replacement parts, fresh-air filter .............................................................................................. 163
Tab. 100 "Temporarily decommissioned" information notice .................................................................... 196
Tab. 101 "Long-term decommissioning and storage" checklist ................................................................. 197
Tab. 102 Text for the "long-term decommissioned and storage" information notice ................................. 198
List of Tables
x
Operator manual Portable compressor
M 64
No.: 9_5898 26 E
RAMIRENT