Knapen Trailers K200 - Page 37

37
User Manual EN | v201906
5.4.1 Loading/unloading with fork-lift
Comply with the following points when loading and unloading using a forklift or hand pallet truck:
Anuncoupledtrailermayneverbeloadedusingafork-lift
Themovingoormustbeintherearmostposition.
TheoorsystemmustNOTbeactivatedwiththefork-lifttruckorhandpallet
truck at loading and unloading.
Whenloading/unloadingataloadingplatform,theoorofthetrailermustbe
level with the loading platform.
Load/unload calmly. No hard braking or acceleration is permitted. Set pallets
etc.ontheoorgently.
Donotmakesharpturnswiththefork-lift.
Avoidsteeringmovementsneartheoorsystem
Floor systems
Iftheaboveprincipleshavebeenmet,thefollowingfork-liftsandloadscandriveonthemovingoorsystem.
Severalvariationsofoorplanksarepossible
Warning: a 15-plank is not suitable for loading and unloading pallets
Options |
Type of moving oor
6 mm, 21 planks
standard proles
10 mm, 21 planks
standard proles
Dura-Floor,
21 planks
Loading/unloading of
general cargo* using the
oorsystem
Yes Yes No
Driving over the moving
oorsystemwithfork-lift
For normal use, i.e. once
a day with a standard 2 T
fork-lift,incl.load
For intensive use, i.e.
more than once a day,
withastandard2.5Tfork-
lift, incl. load
Not permitted
Maximum weight per pallet 1,500 kg 2,000 kg
-
Maximum wheel pressure
per wheel, which includes
the weight of the pallet
1,000 kg 1,500 kg
-
Front tyre width (each) 12 inches (= 305 mm) 12 inches (= 305 mm)
-
Width of the rear tyre (each) 9 inches (= 229 mm) 9 inches (= 229 mm)
-
* General cargo, including pallets, big bags, paper reels etc