Krone X-Disc 620 - 5 Commissioning; Checklist for Initial Operation; Attachment to the Forage Harvester

Commissioning
31
Pos: 45.1 /Überschri ften/Überschri ften 1/A-E/Erstinbetri ebnahme @ 0\mod_119631 4201498_78.docx @ 5855 @ 1 @ 1
5 Commissioning
Pos: 45.2 /BA/Sic herheit/7. Gefahrenhin weise alt/Gefahr - Fehler hafter Zusammenbau @ 1\m od_1202224212591_78.d ocx @ 58171 @ @ 1
Danger! - Incorrect assembly
Effect: Danger to life, serious injuries or serious damage to the machine.
• Only authorised service centres may assemble the machine.
• The machine must be assembled with special care.
• Always heed the applicable accident prevention regulations.
• Use only safe and sufficiently dimensioned lifting equipment and load-securing equipment.
• The machine may be taken into operation only after all the safety devices have been
installed.
• If unauthorised modifications are made to the machine, the manufacturer is released from
liability for any resulting damage.
Pos: 45.3 /BA/Er stinbetriebnahme/Vorsä tze/Vor Erstinbetri ebnahme prüfen und beac hten X-Disc 6200 @ 140\mod_1355 128682538_78.d ocx @ 1244161 @ 2 @ 1
5.1 Checklist for Initial Operation
The following points must be checked and observed.
• Check whether the front attachment for the forage harvester has been released (observe
the operating licence of the forage harvester).
• Lubricate the front attachment thoroughly.
• Check the oil level in the gearboxes.
• Check the screws for firm attachment.
• Check the cutter blades for damage and to make certain they are correctly seated.
• Check the tension of the drive chain(s).
• Completely install the protective equipments and lock them.
• Adapt the adapter frame of the front attachment to the pendulum frame of the forage
harvester.
Pos: 45.4 /Überschri ften/Überschri ften 2/A-E/Anbau an den Feldhäc ksler @ 13\mod_1225451 434551_78.doc x @ 156364 @ 2 @ 1
5.2 Attachment to the forage harvester
Pos: 45.5 /BA/Inbetr iebnahme/Vorsätze/ Adapterrahmen/Hin weis Anbau nur für KRONE-Fel dhäcksler Big X @ 12\mod_1224 669316688_78.doc x @ 152528 @ @ 1
Note
The KRONE direct cutting system X-Disc is specially designed for attachment to the KRONE
forage harvester Big X. Attachment to other harvesters is not permitted without the consent of
KRONE.
Pos: 45.6 /Layout Module /---------------Seitenumbruch---------------- @ 0\mod_119617531122 6_0.docx @ 4165 @ @ 1