4.3.2
4.3.2
4.3.2
4.3.2 STARTUP
STARTUP
STARTUP
STARTUP OF
OF
OF
OF ENGINE
ENGINE
ENGINE
ENGINE
1.
Clear away the persons around the loader and the obstacles in the travelling direction
of the loader; inspect whether there is any person under the loader; except for the
driver who may sit in the cab for operating the loader, no other person may stand on
any portion of the loader.
2.
Turn on the negative pole switch of the battery.
3.
Go up and go down the stairs in accordance with the relevant safety provisions.
4.
Adjust the rear view mirror, so as to obtain a good rear vision which is as closer to the
loader as possible.
5.
Close the left and right doors of the cab.
6.
Inspect whether the seatbelt is in good conditions, and then properly fasten the
seatbelt.
7.
Inspect whether the gear-shift lever is
at
the neutral position; if not, please set the
gear-shift lever
at
the neutral position.
8.
Inspect whether the pilot joystick is
at
the middle position; if not, please set
it
at
the
middle position.
9.
Inspect whether the fan switch and A/C switch of A/C system are
at
the off position; if
not, please set them
at
the off position.
10.
Insert the key into the electric lock and then turn
it
clockwise
by
one step so as to turn
on the power supply, and then sound the horn so as to declare that the loader is
about to start up and no other person may approach the loader.
11.
Inspect the level of fuel.
12.
Slightly push down the accelerator pedal, and turn the key clockwise
by
one more
step so as to switch on the engine starting motor. Under normal conditions, the
engine can be started up within 10 seconds, and then please release the key
immediately so as to let the electric lock return to the original position.
NOTE:
NOTE:
NOTE:
NOTE: An
An
An
An attempt
attempt
attempt
attempt to
to
to
to start
start
start
start up
up
up
up the
the
the
the engine
engine
engine
engine may
may
may
may not
not
not
not last
last
last
last for
for
for
for more
more
more
more than
than
than
than 15
15
15
15 seconds
seconds
seconds
seconds
(the
(the
(the
(the starting
starting
starting
starting motor
motor
motor
motor may
may
may
may not
not
not
not work
work
work
work continuously
continuously
continuously
continuously for
for
for
for more
more
more
more than
than
than
than 15
15
15
15 seconds),
seconds),
seconds),
seconds), and
and
and
and
if
if
if
if the
the
the
the engine
engine
engine
engine cannot
cannot
cannot
cannot be
be
be
be started
started
started
started up,
up,
up,
up, please
please
please
please immediately
immediately
immediately
immediately release
release
release
release the
the
the
the starter
starter
starter
starter
Figure: Inspect the wiring of battery. Connect the
wiring according to the figure.
To Next Page
Loading...