oil pan, and re-check the oil level, if the oil is in shortage, please refill the oil until the
oil falls between “ L" and "H" level of the foot scale.
Change
Change
Change
Change the
the
the
the oil
oil
oil
oil filter
filter
filter
filter when
when
when
when change
change
change
change the
the
the
the engine
engine
engine
engine oil.
oil.
oil.
oil.
5.8.7
5.8.7
5.8.7
5.8.7 REPLACEMENT
REPLACEMENT
REPLACEMENT
REPLACEMENT OF
OF
OF
OF ENGINE
ENGINE
ENGINE
ENGINE OIL
OIL
OIL
OIL FILTER
FILTER
FILTER
FILTER
1. Clean the area near to the install seat of the filter of the engine.
2. Remove the oil filter with the belt wrench.
3. Clean the contact surface of the seal gasket of the install seat with a clean cloth. If
the old O-ring is glued to the install seat, replace it.
4. Install a new O-ring, fill the new oil filter full with clean oil, and seals the contact
surface with a layer of clean engine oil.
5. Install the oil filter to the install seat; tighten
it
to the surface of the oil filter gasket with
install seat. Tighten the oil filter according to the regulated requirement with belt
wrench.
6. Inspect oil level; if the oil is insufficient please add more.
To
To
To
To
tighten
tighten
tighten
tighten the
the
the
the oil
oil
oil
oil filter
filter
filter
filter excessive
excessive
excessive
excessive tight
tight
tight
tight may
may
may
may damage
damage
damage
damage the
the
the
the seals
seals
seals
seals and
and
and
and cause
cause
cause
cause leakage.
leakage.
leakage.
leakage.
5.9
5.9
5.9
5.9 INSPECT
INSPECT
INSPECT
INSPECT ELECTRICAL
ELECTRICAL
ELECTRICAL
ELECTRICAL SYSTEM
SYSTEM
SYSTEM
SYSTEM
The electrical system of the machine is mainly consists of batteries, energy conversion
devices (generator, starter) and power consuming devices (instruments, devices, etc.).
5.9.1
5.9.1
5.9.1
5.9.1 INSPECT
INSPECT
INSPECT
INSPECT BATTERY
BATTERY
BATTERY
BATTERY
1. Inspect in cold weather
In cold weather, if the battery's electrolyte has been frozen, neither recharge the battery,
nor use the other power supply to start the engine, this would cause the batteries on fire;
Battery is shown as the right figure:
Warning
Warning
Warning
Warning
Warning
Warning
Warning
Warning
To Next Page
Loading...