Manitou MLT 961-145 V PLUS L JD ST4 S1 User Manual

3 - 4
LIFT TRUCK MAINTENANCE
DAILY AND WEEKLY MAINTENANCE
t
IMPORTANT
t
THE OPERATOR IS AUTHORISED TO CARRY OUT THIS MAINTENANCE.
These maintenance operations enable the operator to keep the lift truck in a clean, safe condition.
MANDATORY FIRST 500 HOURS OR 6 MONTH SERVICE
t
IMPORTANT
t
THIS SERVICE MUST BE CARRIED OUT AFTER APPROXIMATELY THE FIRST 500 HOURS OF SERVICE OR WITHIN THE 6 MONTHS
FOLLOWING THE START-UP OF THE MACHINE
(WHICHEVER OCCURS FIRST).
PERIODIC MAINTENANCE
t
IMPORTANT
t
THE PERIODIC MAINTENANCE MUST BE CARRIED OUT BY A PROFESSIONAL APPROVED BY THE MANITOU NETWORK
MAINTENANCE SCHEDULE
This schedule enables the operator to remain up-to-date with the periodic maintenance carried out on the lift truck by
notifying the total number of hours of operation completed and the date of the service carried out by the MANITOU network
approved professional.
OCCASIONAL MAINTENANCE AND OPERATION
These maintenance and other operations are carried out as required to ensure the safety and correct maintenance of the lift
truck.
DAILY AND WEEKLY MAINTENANCE
Ü
10 HOUR - DAILY MAINTENANCE OR EVERY 10 HOURS OF SERVICE
- CHECK Area around the lift truck ........................................................ 3-12
- CHECK I.C. engine oil level............................................................... 3-12
- CHECK Coolant level .................................................................... 3-12
- CHECK Fuel pre-filter .................................................................... 3-13
- LUBRICATE Boom pads* ..................................................................... 3-13
* Every 10 hours during the first 50 hours, then a last time after 250 hours.
- CHECK Signalling device and longitudinal stability limiter ................................ 3-14
Ü
50 HOUR - DAILY MAINTENANCE OR EVERY 50 HOURS OF SERVICE
- CHECK Gearbox oil level................................................................. 3-16
- CHECK Tyre pressure .................................................................... 3-16
- CHECK Wheel nut torque................................................................ 3-16
- CHECK Waterproofing on front axle differential .......................................... 3-17
- CHECK Waterproofing on rear axle differential ........................................... 3-17
- CHECK Waterproofing of front wheel reducing gears ..................................... 3-17
- CHECK Waterproofing of rear wheel reducing gears ...................................... 3-17
- CHECK Brake oil level ................................................................... 3-17
- CHECK Hydraulic oil level................................................................ 3-18
- CHECK Windscreen washer liquid level................................................... 3-18
- CLEAN Radiator grilles .................................................................. 3-19
- CLEAN/CHECK Condenser grille (OPTIONAL air conditioning) .................................... 3-19
- LUBRICATE General lubrication .............................................................. 3-20
649100 EN-US-AU (20/05/2019) MLT 961-145 V PLUS L JD ST4 S1

Manitou MLT 961-145 V PLUS L JD ST4 S1 Specifications

General

Brand	Manitou
Model	MLT 961-145 V PLUS L JD ST4 S1
Category	Front End Loaders
Language	English