Troubleshooting
6-12
Part 1126931_01
2018 Nordson Corporation
Error Messages
Error Code
(Hex)
Error Code
(Dec)
Fault Type
Keypad Description
0x2220 8736 Fault OC power mod. CiA: Continuous over current (device internal)
0x2230 8752 Fault F.Ground short CiA: Short circuit/earth leakage (device inter- nal)
0x2250 8784 Fault OC pm short CiA: Short circuit (device internal)
0x2351 9041 Configurable OL i2t motor CiA: Load level fault (I2t, thermal state)
0x2382 9090 Configurable F.ixt Ixt fault
0x2383 9091 Warning W.ixt Ixt warning
0x3000 12288 Fault F.Su02 Single phase fault
0x3210 12816 Fault F.OU DC link circuit over-voltage
0x3220 12832 Trouble F.LU DC link circuit under-voltage
0x4210 16912 Fault F.OH1 Power module overtemperature fault
0x4211 16913 Warning W.OH1 Power module overtemperature warning
0x4310 17168 Configurable OT motor Motor temperature has reached error level
0x4481 17537 Fault sens. heatSink Heat sink temperature sensor fault
0x5003 20483 Fault F.ID1 Motor parameter identification fault
0x5112 20754 Warning W.24V supply 24V supply level critical
0x5581 21889 Fault Programming err Power unit programming fault
0x5582 21890 Fault EPM full EPM full
0x5584 21892 Fault Eeprom fault On-board eeprom access failure
0x5585 21893 Fault EPM store E EPM data was not completely saved before power
down
0x6104 24836 Warning Watchdog reset Watchdog time-out
0x610A 24842 Fault F.dF12 Math error
0x6181 24961 Fault OL 125us task Calculation time overrun in 125us task
0x6182 24962 Fault OL 250us task Calculation time overrun in 250us task
0x6183 24963 Fault OL 1ms task Calculation time overrun in 1ms task
0x6184 24964 Fault OL 8ms task Calculation time overrun in 8ms task
0x6200 25088 Fault User set fault 1 Digital connection list user fault 1
0x6201 25089 Fault User set fault 2 Digital connection list user fault 2
0x6307 25351 Fault F.AL Assertion level fault
0x8100 33024 Configurable CAN bus off CAN bus off
0x8101 33025 Configurable CAN bus warning CAN warning
0x8109 33033 Configurable Stack init error Fieldbus communication stack initialization error
Continued...
To Next Page
Loading...
