Telescopic Boom Series
Models SJ61T & SJ66T
194312
December 2007 Page 109
4
Section 4
TROUBLESHOOTING INFORMATION
Table of Contents
Introduction ..............................................................................................................................................................111
4.1 Electrical System
4.1-1 All Controls Inoperative...................................................................................................................................112
4.1-2 No Power To Platform .....................................................................................................................................112
4.1-3 No Power to Base ...........................................................................................................................................113
4.1-4 Engine Will Not Crank from Base ...................................................................................................................113
4.1-5 Engine Will Not Crank from Platform ..............................................................................................................113
4.1-6 Engine Will Not Crank from Platform or Base (Deutz TD2.9L).......................................................................114
4.1-7 Engine Cranks but Will Not Start (Deutz TD2.9L) ..........................................................................................114
4.1-8 Engine Will Not Crank from Platform or Base (Deutz Diesel D2011).............................................................115
4.1-9 Engine Cranks but Will Not Start (Deutz Diesel D2011)
................................................................................115
4.1-10 Engine Will Not Crank from Platform or Base Control (GM Dual Fuel) .......................................................116
4.1-11 Engine Cranks but Will Not Start (GM Dual Fuel) ........................................................................................117
4.1-12 Glow Plug Circuit Inoperative .......................................................................................................................119
4.1-13 All Controls Inoperative from Base Console ................................................................................................119
4.1-14 No Boom Up from Base Control Console ....................................................................................................120
4.1-15 No Boom Down from Base Control Console ...............................................................................................120
4.1-16 No Turret Rotate Left from Base Control Console ........................................................................................120
4.1-17 No Turret Rotate Right from Base Control Console .....................................................................................121
4.1-18 No Telescope Retract From Base Control Console .....................................................................................121
4.1-19 No Telescope Extend From Base Control Console......................................................................................121
4.1-20 No Platform Rotate Left From Base Control Console ..................................................................................122
4.1-21 No Platform Rotate Right from Base Control Console .................................................................................122
4.1-22 No Platform Rotate Left or Right from Base Control Console......................................................................123
4.1-23 No Jib Up from Base Control Console .........................................................................................................123
4.1-24 No Jib Down from Base Control Console ....................................................................................................123
4.1-25 No Jib Up Or Down From Base Control Console ........................................................................................124
4.1-26 No Manual Platform Level Up From Base Control Console.........................................................................124
4.1-27 No Manual Platform Level Down From Base Control Console ....................................................................125
4.1-28 No Manual Platform Level Up From Platform Control Console ...................................................................125
4.1-29 No Manual Platform Level Down From Platform Control Console...............................................................126
4.1-30 All Controls Inoperative From Platform Control Console .............................................................................126
4.1-31 No Boom Up From Platform Control Console .............................................................................................127
4.1-32 No Boom Down From Platform Control Console .........................................................................................127
4.1-33 No Turret Left from Platform Control Console ..............................................................................................128
4.1-34 No Turret Right from Platform Control Console ...........................................................................................129
4.1-35 No Telescope Out from Platform Control Console .......................................................................................129
4.1-36 No Telescope Out from Platform Control Console .......................................................................................130
4.1-37 No Platform Rotate or Jib Function from Platform Control Console ............................................................131
4.1-38 No Platform Rotate Left from Platform Control Console ..............................................................................131
4.1-39 No Platform Rotate Right from Platform Control Console ...........................................................................131
4.1-40 No Jib Up from Platform Control Console....................................................................................................132
4.1-41 No Jib Down from Platform Control Console
...............................................................................................132
4.1-42 Throttle Inoperative, Mid and High (Deutz TD2.9L only) ..............................................................................132
4.1-43 Mid Throttle Inoperative ................................................................................................................................133
To Next Page
Loading...
Need help?
General
