Suzuki LT-Z90K7 2007 - Initial Engagement and Clutch Lock-Up Inspection; Initial Engagement Inspection

PERIODIC MAINTENANCE 2-29
INITIAL ENGAGEMENT AND CLUTCH LOCK-UP INSPECTION
The LT-Z90 is equipped with a centrifugal type automatic clutch.
To insure proper performance and longevity of the clutch
assemblies it is essential that the clutches engage smoothly and
gradually. Before checking the initial engagement and clutch
lock-up two inspection checks must be performed to thoroughly
check the operation of the drive train. Perform the following:
• Warm up the engine.
INITIAL ENGAGEMENT INSPECTION
• Connect the multi-circuit tester onto the spark plug high-ten-
sion cord.
• Start the engine.
• Slowly open the throttle and note the engine speed (r/min)
when the vehicle begins to move forward.
\ 09900-25008: Multi-circuit tester set
 Engagement speed: 2 800 – 3 400 r/min
If the engagement speed does not coincide with the standard
range, inspect the following items for any abnormalities.
* Clutch shoe .................................................

3-54
* Clutch housing.............................................

3-54
* Movable drive and driven face ....................

3-51