turbofan 30D Series Service Manual

Contents List
Amendment 10
11 May 2015
G32 Turbofan Convection Oven.
Model Numbers Covered in this Manual
G32D4 - Turbofan Oven - 4 Tray Convection Oven.
G32D5 - Turbofan Oven - 5 Tray Convection Oven.
Specifications ........................................................................................................................... 2
Installation ............................................................................................................................... 4
Installation Requirements
Unpacking
Location
Clearances
Stand Mounted Ovens
Electrical Connection
Gas Connection
Recommended Water Specifications
Water Connection
Positioning and Levelling of Oven
Stand Mounted Ovens
Initial Start-Up
Commissioning
Operatio n .................................................................................................................................. 7
Oven Control Panel (Up to Ser. No. 762119)
Oven Control Panel (From Ser. No. 762120)
Changing Operator Settings
Operator Settings
Parts Replacement ................................................................................................................. 10
5.1 Parts Replacement
5.2 Adjustment and Calibration
Controller Programming ........................................................................................................ 22
6.1 Viewing / Changing Service Parameters
6.2 Viewing / Changing Service Parameters (Up to Ser No. 762119)
6.3 Viewing / Changing Service Parameters (From Ser No. 762120)
E
lectrical Schematics ............................................................................................................. 26
Wiring Diagrams..................................................................................................................... 2
7
Exploded Parts Lists ............................................................................................................... 2
9
Accessories ............................................................................................................................ 3
6
Gas Conversion and S
pecifications ........................................................................................ 37
Appendix 1 - Oven Door Reversal ........................................................................................... 39
ALL INSTALLATION AND SERVICE REPAIR WORK MUST BE CARRIED OUT BY QUALIFIED PERSONS ONLY.
IMPROPER INSTALLATION, ALTERATION, ADJUSTMENT, MAINTENANCE OR SERVICE MAY CAUSE PROPERTY
DAMAGE, INJURY OR DEATH.
ENSURE ELECTRIC AND GAS SUPPLIES ARE TURNED OFF BEFORE SERVICING.
ALWAYS TEST AFTER SERVICE REPAIRS
WARNING:

turbofan 30D Series Specifications

General

Brand	turbofan
Model	30D Series
Category	Commercial Food Equipment
Language	English