Benelli TRK 502 User Manual

EN
6
6 - 16
Periodic maintenance and adjustment
Checking the throttle grip free play
Measure the throttle grip free play as shown.
Periodically check the throttle grip free play
and, if necessary, have a Benelli dealer adjust
it.
Valve clearance
The valve clearance changes with use, resul-
ting in improper air-fuel mixture and/or engi-
ne noise. To prevent this from occurring, the
valve clearance must be adjusted by a Benelli
dealer at the intervals specied in the periodic
maintenance and lubrication chart.
Tires
Tires are the only contact between the vehicle
and the road. Safety in all conditions of riding
depends on a relatively small area of road
contact.
Therefore, it is essential to maintain the tires
in good condition at all times and replace
them at the appropriate time with the speci-
ed tires.
Tire air pressure
The tire air pressure should be checked and, if
necessary, adjusted before each ride.
WARNING
Operation of this vehicle with improper
tire pressure may cause severe injury or
death from loss of control.
• The tire air pressure must be checked
and adjusted on cold tires (i.e., when
the temperature of the tires equals
the ambient temperature).
• The tire air pressure must be adjusted
in accordance with the riding speed
and with the total weight of rider, pas-
senger, cargo, and accessories appro-
ved for this model.
Throttle grip free play
Throttle grip free play:
3.0 - 5.0 mm (0.12 - 0.20 in)

Benelli TRK 502 Specifications

General

Displacement	500 cc
Transmission	6-speed
Fuel Tank Capacity	20 liters
Seat Height	800 mm
Wet Weight	235 kg
Bore x Stroke	69 mm x 66.8 mm
Compression Ratio	11.5:1
Clutch	Wet multi-plate
Frame	Steel trellis
Wheelbase	1505 mm
Ground Clearance	190 mm
Max Power	47.6 hp (35 kW) @ 8500 rpm
Max Torque	46 Nm @ 6000 rpm
Front Suspension	50 mm upside-down fork
Front Brake	Double floating discs, 320mm, 4-piston calipers
Rear Brake	Single 260 mm disc
Fuel System	Electronic Fuel Injection (EFI)
ABS	Dual-channel ABS
Front Tire	120/70 R17
Rear Tire	160/60 R17
Engine Type	Liquid-cooled, four-stroke, parallel twin cylinder, DOHC, 4 valves per cylinder