1–1 62-12259
SECTION 1
Safety Precautions
1.1 Safety Precautions
WARNING
!
SAFETY CONSIDERATIONS: Installation and servicing of refrigeration equipment can be haz-
ardous due to system pressures, rotating elements and electrical components. Only trained
and qualified service personnel should install, repair or service refrigeration equipment. When
working on refrigeration equipment, observe precautions in all literature including this manual,
the equipment tags and labels attached to the unit, and other safety precautions that may
apply. Follow safe work practices and utilize the appropriate protective equipment at all times.
Your Carrier Transicold refrigeration unit has been designed with the safety of the operator in mind. During normal
operation, all moving parts are fully enclosed to help prevent injury. During all pre-trip inspections, daily inspec-
tions, and problem troubleshooting, you may be exposed to moving parts. Please stay clear of all moving parts
when the unit is in operation and when the START/RUN-OFF switch (SROS) is in the START/RUN position.
Automatic Start-Stop
Your refrigeration unit is equipped with auto-start in both Start-Stop and Continuous Operation. The unit may start
at any time the START/RUN-OFF switch (SROS) is in the START/RUN position. A buzzer will sound for five sec-
onds before the unit is started. When performing any check of the refrigeration unit (e.g., checking the belt, check-
ing the oil, checking the electrical connections), make certain that the START/RUN-OFF switch is in the OFF
position.
Engine Coolant
The engine is equipped with a pressurized cooling system including a pressurized coolant bottle. Under normal
operating conditions, the coolant in the engine and radiator is under high pressure and is very hot. Contact with hot
coolant can cause severe burns. Do not remove the cap from a hot coolant system. If the cap must be removed,
cover it with a rag and remove very slowly in order to release the pressure without spray.
Refrigerants
The refrigerant contained in the refrigeration system of this unit can cause frostbite, severe burns, or blindness
when in direct contact with the skin or eyes. For this reason (and because of legislation regarding the handling of
refrigerants) we recommend that you contact your nearest Carrier Transicold authorized repair facility whenever
service of the refrigerant system is required.
Battery
This unit may be equipped with a lead-acid type battery. The battery normally vents small amounts of flammable
hydrogen gas. Do not smoke when checking the battery. A battery explosion can cause serious physical harm and/
or blindness.
To Next Page