Carrier TRANSICOLD Vector 8700 - Page 287

374 pages

Save Page as PDF

To Next Page

To Previous Page

8–17 62-12259

8.5.13 Breather

The breather consists of a breather valve, diaphragm and breather pipe. The breather is fitted with a diaphragm

type valve and mitigates pressure changes in the crankcase.

Figure 8.14 Breather

Main Page

Table of Contents5
Safety Precautions11
Automatic Start-Stop11
Specific Warning, Caution, and Notice Statements12
Safety Decals16
Unit Description19
Introduction19
General Description19
Condensing Section25
Engine25
Engine Air System25
After Treatment System25
Engine Controls25
Generator (GEN)26
Compressor26
Compressor Switches, Transducers and Sensors26
Liquid Injection Solenoid Valve (LIV)26
Condenser Coil27
Economizer Circuit27
Economizer Transducer and Sensor27
Ambient Air Temperature Sensor (AAT)27
Compressor Suction Modulation Valve (CSMV)27
Filter Drier27
Receiver27
Autofresh Air Exchange27
Evaporator Section28
Evaporator Coil28
Evaporator Expansion Valve (EVXV)28
Evaporator Switches, Transducers and Sensors28
System Operating Controls and Components29
Multiple Languages29
Automatic Start-Stop29
Special Features29
Component Description and Location29
Options34
TRU Status Light / Light Bar34
Remote Switch(Es)35
Remote Temperature Sensor36
Fuel Level Sensor36
Fuel Heater36
Electric Fuel Pump36
Remote Panel36
Water in Fuel (WIF) Sensor36
Engine Data37
Specification37
Lubrication System37
Compressor Data37
Refrigeration System Data38
2.10 Electrical Data38
2.11 Component Resistance and Current Draw39
2.12 Safety Devices40
2.13 Refrigeration Circuit During Cooling40
Standard Mode40
Economized Mode41
Null Mode41
Liquid Injection Mode41
2.14 Heat and Defrost41
Operation45
Display45
Display Screens46
Starting Unit47
Inspect Mode48
Switching Operating State49
Intelliset51
Pretrip53
Changing Setpoint56
Start-Stop Operation57
3.10 Continuous Operation58
3.11 Data Recorder59
APX Control System Information59
Data Recording59
Data Downloading60
Data Recorder Power-Up60
3.12 Manual Defrost61
3.13 Language Selection62
3.14 Advanced User63
Unit Data65
Fuel Level65
Remote Sensor65
Discharge Pressure66
Refrigeration System66
System Information66
3.16 View Active Alarms67
3.17 View Hour Meters68
3.18 Functional Parameters69
Wake up Time72
3.19 Sleep Mode73
3.20 Stopping the Unit75
3.21 Option - Datatrak76
3.22 Emergency Bypass Mode77
Entering Emergency Bypass Mode77
Exiting Emergency Bypass Mode77
3.23 Remote Panel78
Engine and Temperature Control81
Introduction81
Sequence of Operation - Electrical81
Engine/Electric Operation82
Soft Start (Bump Start)82
Loss of Standby Power83
Engine Control83
Engine Start-Up Sequence83
Transition to High Speed84
Start-Stop Operation84
Start-Stop Configuration85
Stop Parameters86
Re-Start Parameters87
Continuous Operation88
Temperature Control88
Perishable and Frozen Setpoint Ranges88
Temperature Determination88
Cool/Heat/Null Mode Switching Logic88
Cool Mode89
Heat Mode89
Null Mode89
Autofresh Air Exchange91
Defrost92
Defrost Initiation and Start92
Defrost Modes93
Defrost Termination93
User Selected Override Operation93
Fresh Protect93
Temperature Range Lock 1 and 293
Productshield95
4.10 Preprogrammed Software Overrides97
High Discharge Temperature97
Cargo Protect Mode98
Engine Speed Overrides98
High Voltage98
CSMV Control Overrides99
Compression Ratio99
Control System Interface101
Interface Methods101
Technician Mode101
Technician Hour Meters102
Inactive Alarms103
Configuration Settings105
Component Test Mode107
Service Mode108
Usb Memory Devices109
Data Transfer USB Memory Device109
PC Mode110
Downloading Data Files111
Installing Software112
Transferring Configuration Files115
Tru-Tech and Tru-View116
TRU-Tech116
TRU-View116
Connecting Computer and Control System116
Main Microprocessor Replacement and Setup117
Pre-Replacement Steps118
Microprocessor Stepper Module Replacement118
Microprocessor Setup119
Configurations Via Display Mounted Keys120
Unit Model Number121
Unit Serial Number121
Set Date and Time121
Door Switch128
Alarm Delay129
Alarm Troubleshooting139
Engine Oil152
Temperature Sensor153
Corrective Actions158
Check Starter161
Check Engine166
Check Wiring171
Check Sensor191
Corrective Actions194
Corrective Actions221
Reset Microprocessor225
Check Sensor249
Pretrip Inspection272
Operation273
Solenoid Replacement274
Cable Replacement276
Cooling System284
Radiator Replacement285
Coil Replacement314
Pressure Transducers316
Generator Removal333

Related product manuals

Carrier TRANSICOLD VECTOR 8100

294 pages

PrimeLINE 69NT40-571-001

186 pages

PrimeLINE 69NT40-571-199

186 pages

eSolutions Supra 60 Series

39 pages

Carrier TRANSICOLD Integra 35X

80 pages

Carrier TRANSICOLD 69NT40-489

172 pages

Carrier TRANSICOLD Supra 560

42 pages

eSolutions Supra 960

39 pages

Carrier TRANSICOLD Supra 760

42 pages

Carrier TRANSICOLD Supra 860

42 pages

Carrier TRANSICOLD Supra 660

106 pages

Carrier TRANSICOLD Vector 8700 - Page 287

Table of Contents

Related product manuals