EasyManua.ls Logo

GILES GBF-70 - User Manual

GILES GBF-70
108 pages
Save Page as PDF
Print Icon
To Next Page IconTo Next Page
To Next Page IconTo Next Page
Loading...
ISO 9001 Registered • Committed to Quality
2750 Gunter Park Drive West • Montgomery, AL 36109 USA
Phone: 334.272.1457 • Toll Free: 800.554.4537 (USA & Canada Only)
Fax: 334.239.4117 • Website: www.gfse.com
Printed in USA, Form No.66320 (Rel. Date: Nov.2019, Rev. A)
GBF-70 Electric Fryer
Operations & Service Manual
Banked Units
Double or Triple
Single Unit

Table of Contents

Questions and Answers

  • J
    jamie52Aug 25, 2025
    Why is the oil not circulating in my GILES GBF-70 during filtering?
    • G
      Gary WarnerAug 26, 2025
      If the oil in your GILES Fryer doesn’t circulate or return to the refill vat when filtering, there could be several reasons. First, the oil might be too cold to pump; manually remove the thick oil from the pan. Second, the filter pan might be packed with excessive cooking residue, preventing the pump from drawing; clean the filter pan and refresh the filter media. Third, the filter pan might be assembled incorrectly; verify that the pan is assembled properly. Finally, air might be leaking into the filter plumbing; verify that the filter pan hose connection is secure.
  • T
    Tracy MezaAug 26, 2025
    What causes oil circulation problems during filtering in my GILES Fryer?
    • L
      Lauren HollowayAug 26, 2025
      If the oil in your GILES Fryer doesn’t circulate or return to refill vat when filtering, and you always refer to the Controller Upper Display for alarm error messages and/or operational prompts & instructions, it means that the automated OIL RETURN valve has failed to OPEN, causing the pump to shut down due to high pressure. A service technician is required.
  • T
    Tina RichardsAug 27, 2025
    What to do if my GILES GBF-70 Fryer is not heating up?
    • T
      tanner65Aug 27, 2025
      If your GILES Fryer is not heating, the control panel POWER light is on, the HEAT switch is in the HEAT position, but the control panel amber HEAT light is off, and the controller HEAT indicator is off, consider the following: * If a “POWER FAILURE” message is showing, press the START key to enter PREHEAT mode. * Verify that the actual oil temperature is not higher than the controller setpoint. After a boil-out cycle, the setting automatically changes to 50°F. * Also, check if a “DRAIN OPEN” message is displayed with an alarm, and ensure the drain valve is fully closed. If none of these steps resolve the issue, it could be due to a faulty controller, temperature sensor, contactor, or HEAT switch, in which case you should call for service.
  • D
    Deborah GloverAug 27, 2025
    How to fix a GILES Fryer that won't turn on?
    • M
      Martha MitchellAug 27, 2025
      If your GILES Fryer will not turn on and the POWER light on the Control Panel is not illuminated, there are a few potential causes. First, check the kitchen's electrical panel to ensure that the circuit breaker has not tripped, and reset it if necessary. Second, inspect the fryer's fuses, located inside the cabinet in the upper right-hand corner, and replace any blown fuses. If neither of these resolves the issue, the power switch may be faulty, requiring a service technician.
  • D
    David SmithAug 28, 2025
    What to do if my GILES Fryer stops heating and the high-limit trips?
    • G
      Gabrielle HunterAug 28, 2025
      If your GILES Fryer stops heating and the high-limit trips before reaching the setpoint, and the POWER, HEAT, and Controller HEAT lights are on, while the Red HILIMIT light is on, it indicates that the Hi-Limit thermostat has failed. A service technician is required to address this issue.
  • M
    meagansmithAug 29, 2025
    Why does my GILES Fryer keep heating until the high-limit trips?
    • S
      schneidersarahAug 29, 2025
      If the GILES Fryer continues heating until the high-limit trips, with the POWER, HEAT, and Controller HEAT lights on, and the Red HILIMIT light also on, it suggests that the temperature probe has failed. A service technician is required to resolve this issue.
  • N
    Natalie KeithAug 30, 2025
    Why doesn't the controller power up on my GILES GBF-70 Fryer?
    • R
      Richard Black DDSAug 30, 2025
      If the Controller on your GILES Fryer doesn’t power up, but the POWER light on the Control Panel is on, it may be due to a blown controller power supply fuse or a controller failure. A service technician is required to address either of these issues.
  • A
    Alan ThomasAug 23, 2025
    What to do if my GILES Fryer will not turn on?
    • M
      Mario WilliamsAug 25, 2025
      If your GILES Fryer won't turn on and the POWER light on the control panel isn't lit, here's what you can check: * First, check the facility electrical panel for a tripped circuit breaker and reset it if necessary. * Next, inspect the fuses in the fryer, replacing them if needed. They are located inside the cabinet, in the upper right-hand corner. * If neither of these steps resolves the issue, the power switch may be faulty, and you should call for service.
  • S
    Sophia KimAug 31, 2025
    How to enable the basket lift on my GILES GBF-70 Fryer?
    • M
      Martha WatsonAug 31, 2025
      If the basket lift on your GILES Fryer will not operate, check the LIFT switch on the Control Panel. If it's in the OFF position, place it in the LIFT position to enable the lifts.
  • J
    Jessica HowardSep 1, 2025
    Why does the filter pump in my GILES GBF-70 Fryer stop after starting?
    • J
      Julie JohnsonSep 2, 2025
      If the filter pump in your GILES Fryer starts, runs briefly, and then stops, it indicates that the pressure switch has shut down the pump due to high pressure to avoid blown seals. This could be due to pumping against a closed valve or a solid blockage. Verify the valve operation. If needed, call a service technician.

Summary

Limited Warranty Information

Safety Guidelines and Precautions

Safety Overview

General introduction to safety information, symbols, and usage notes.

Specific Safety Precautions

Detailed safety guidelines for operating and servicing the fryer.

Introduction to the GBF-70 Fryer

Construction Details

Details on the materials and build of the fryer unit.

Standard Features

Overview of key features integrated into the standard fryer model.

Optional Features

Description of available add-on features for the fryer.

Specifications and Dimensions

Technical specifications including dimensions, certifications, and capacities.

Installation Procedures

Appliance Location

Guidelines for selecting a suitable and safe installation site for the fryer.

Unpacking the Fryer

Procedures for safely removing the fryer from its shipping packaging.

Electrical Requirements and Connections

Information on power supply needs, specifications, and wiring procedures.

Fryer Options Installation

Explanation of installing optional features like oil management and top-off systems.

Ventilation and Restraint Device

Requirements for ventilation installation and securing the fryer unit.

Finalizing Installation and Testing

Steps to complete installation and initial functional checks.

Overview of Fryer Components

Control Panel Description

Detailed description and diagram of the fryer's control panel.

Lower Cabinet Components

Identification of components within the fryer's lower cabinet.

Filter Pan Assembly Details

Explanation of the filter pan's components and function.

Basket and Oil Systems

Overview of basket lifting and oil storage systems.

Included Accessories

List and description of accessories provided with the fryer.

Not Provided Accessories

List of recommended accessories that are not included.

Fryer Operation Guide

The Computer Controller Operations

Comprehensive guide to operating the dual-timer computer controller.

Cooking Procedures

Detailed steps for cooking food items using the fryer.

Optional Oil Level Top-Off System

How to use the feature for maintaining oil levels.

Filtering Used Cooking Oil

Instructions for filtering and reconditioning cooking oil.

Fryer Shutdown Procedures

Standard and emergency procedures for turning off the fryer.

Cleaning and Maintenance Procedures

Removing and Disposing of Waste Cooking Oil

Process for safely draining and disposing of used cooking oil.

Boil-Out Procedure for Fry Vat Cleaning

Method for deep cleaning the fryer vat using the boil-out process.

Cleaning Filter Pan and Refreshing Media

Procedures for cleaning the filter pan and replacing filter media.

Troubleshooting Common Issues

Temperature Control System Problems

Solutions for issues related to fryer heating and temperature regulation.

On-Board Oil Filtration Problems

Troubleshooting common issues with the oil filtration system.

Oil Top-Off System Issues

Diagnosing and resolving problems with the oil top-off feature.

Filter Pump Problems

Identifying and fixing issues with the filter pump operation.

Basket Lift System Issues

Troubleshooting common problems with the basket lift mechanism.

Replacement Parts List

Parts Ordering and Service Information

How to order replacement parts and obtain service.

Control Panel Parts

List of parts for the fryer's main control panel.

Lower Cabinet Parts

Parts list for the main unit's lower cabinet components.

Plumbing Components

List of plumbing parts for single and double bank fryer units.

Rear Cabinet Parts

Parts diagram and list for the rear cabinet of single and double units.

Fry Vat Assembly Parts

Components of the fryer vat assembly.

Filter Pan Assembly Parts

Breakdown of the filter pan and its associated parts.

Appendix A: Optional KITCHENTRAC Connectivity

Connecting WiFi Board to Wireless Router

Steps to connect the fryer's WiFi module to a wireless router.

Establishing Communication with KitchenTrac

Procedure for establishing communication with the KitchenTrac server.

WiFi Components Identification

Identification of the WiFi hardware components.

GILES GBF-70 Specifications

General IconGeneral
BrandGILES
ModelGBF-70
CategoryFryer
LanguageEnglish

Related product manuals