Kioti RX8030 - Page 40

252 pages

Save Page as PDF

To Next Page

To Next Page

To Previous Page

To Previous Page

Loading...

MEMO

MEMO

TF120(RX6030,7030,8030)-AU-01.in28 28 2015-10-29 오후 6:38:00

Table of Contents

Default Chapter4
- Table of Contents4
- Precautions before Operation14
  - General Precautions14
Precautions before Operation17
Precautions DURING Operation17
- When Starting the Engine17
- Specifications20
- When Driving the Tractor21
- When Parking the Tractor23
- When Operating the Pto23
- When Using the 3-Point Hitch24
Safety Precautions DURING Servicing24
Safety Precautions When USING the Loader29
Safety Decal Maintenance32
- Decal Mounting Location (Cabin)32
- Decal Mounting Location (Rops)34
- Decals36
- Cautions for Decal Maintenance39
Vehicle Identification Number42
- Tractor Serial Number42
- Engine Serial Number42
- Transmission Serial Number42
- Essential Replacement PARTS44
- Oils and Fluids44
- Filters44
- Belts and Rubber Parts45
- Other Components45
- Specifications47
Description of Operating System61
- Exterior View (CABIN)64
- Exterior View (ROPS)65
- Switch Mounting LOCATION66
- Key Switch68
- Combination Switch69
- Hazard Lamp Switch70
- 4Wd Switch71
- Pto Switch73
- Pto Selection Switch74
- Dpf Regeneration Switch74
- Clutch Pedal Engagement Control Button75
- Pto Cruise76
- Calibration Switch77
Instrument Panel78
Loader Operation81
3 Point Hitch Implement and81
3 Point Hitch81
- Tachometer/Hourmeter81
  - Fuel Gauge81
Maintenance81
- Engine Coolant Temperature Gauge82
- Turn Signal Lamp82
- Battery Charging Lamp83
- Head Light High Beam Lamp83
- Glow Plug Indicator84
- Engine Oil Pressure Warning Lamp84
- Differential Lock Warning Lamp85
- Air Filter Warning Lamp85
- Quick / Turn Warning Lamp (if Equipped)85
- 4Wd Indicator86
- Indicator86
- M Indicator86
- Indicator87
- Pto Indicator87
- Parking Brake Warning Lamp87
- Low Fuel Level Warning Indicator88
- Coolant Temperature Warning Lamp88
- Water in Fuel Warning Lamp88
- Regeneration Warning Lamp89
- Regeneration Underway Lamp89
- Engine Check Warning Lamp89
- Cruise Pto Warning Lamp90
- Brake (One Side) Lamp90
- Speed Limit Switch91
- Cruise Control Switch91
- No Stall Switch92
- Error Indicator93
Operating the CONTROLS94
- Main Shift Lever97
- CABIN System111
- Interior Devices111
- Exterior Devices112
- Antenna118
- Cabin Lamp118
- Accessory119
- Sun Visor (if Equipped)120
- Recirculation/Fresh Air Mode121
- Heater and Air Conditioner122
- 7-Pin Power Output Socket125
- Tires, Wheels and Ballast126
- Inflation Pressure127
Operation137
- Pre-Operation Check138
- Operating the Engine139
- Starting the Engine139
- Checking Warning Lamps142
- Stopping the Engine143
- Warming up144
- Jump Starting145
- Operating the TRACTOR146
- How to Drive146
- Parking150
- Turning151
- Driving on Slopes152
- Precautions When Coming in and out of Work Field152
- Loader Operation152
- Precautions While Driving on the Road153
- Loading and Unloading154
- Precautions When Using Power Steering154
- 3-Point Hitch Control System156
- Remote Hydraulics160
- Connecting and Disconnecting Implement162
3-POINT Hitch Implement and Loader Operation165
- Removal and INSTALLATION of 3-POINT Hitch Implement (with PTO Shaft)166
- Operation TIP for 3-POINT Hitch Elements169
- Adjustment of Lift Rod169
- Adjustment of Top Link170
- Precaution for Installing / How to Use Top Link Holes170
- Adjustment of Stabilizer171
- Dismounting the Implement171
- Draw Bar and Trailer171
- Installing Pto Shaft173
Handling Loader175
- Fixation Points for Front End Loader176
- Driving on Slopes177
- Joystick Lever178
- Joystick Valve Port181
Maintenance Check LIST185
- Daily Check Chart185
- Maintenance Schedule Chart186
  - Lubricants190
Lubricants191
Maintenance Code191
- How to Open the Hood (A)191
- Checking and Adding Fuel (B)191
- Checking Transmission Fluid Level (C)192
- Checking Engine Oil Level (D)193
- Checking Coolant Level (E)194
- Cleaning Grill, Radiator Screen (F)195
- Checking Seat Belt and Cabin (J)196
  - Changing Engine Oil and Replacing Filter (K)196
  - Replacing Transmission Fluid and Filter (L)198
- Inspection Front Axle Case Oil (M1)199
- Changing Front Axle Case Oil (M2)200
- Adjusting Brake Pedal (N)200
- Lubricating Grease Locations (O)202
- Checking Wheel Bolt/Nut Torque (P)203
- Adjusting Clutch Pedal (Q)203
- Replacing Air Cleaner Primary Element (R)204
- Fuel Filter (S)205
Bleeding Fuel System (T)206
- Adjusting Fan Belt Tension (U)207
- Battery (V)208
- Checking Intake Air Line (W)210
- Adjusting Toe-In (X)210
  - Checking Radiator Hose and Clamp (Y)211
- Power Steering Line (Z)212
- Air Conditioner Belt Tension (Aa)212
  - Cleaning Air Conditioner Condenser (Ab)213
- Adjusting Front Axle Pivot (Ac)213
  - Adjusting Engine Valve Clearance (Ad)214
- Replacing Air Cleaner Filter (Ae)214
- Checking Air Conditioner Hose (Af)215
  - Checking Cab Cushion Rubber (Ag)215
  - Flush Cooling System and Changing Coolant (Ai)215
  - Checking Air Conditioner215
- Hose (Af)215
- Replacing Air Filter (Ah)215
- Coolant (Ai)216
- Anti-Freeze217
  - Draining Water from Clutch Housing (Aj)217
  - Checking and Replacing Wiper (Ak)218
- Replacing Cabin Fuse (Al)220
- Main Fuse (Am)222
- Replacing Bulb (An)223
- Troubleshooting223
- Checking Refrigerant (Ao)228
- Air Conditioner Maintenance (Ap)228
- Turbocharger (Aq)229
Storage and DISPOSAL231
Storage and Disposal232
TRACTOR Storage232
- Daily Storage232
- Long-Term Storage232
- Using Tractor after Storage234
Usage and DISPOSAL235
Troubleshooting237
Engine Troubleshooting238
TRACTOR Troubleshooting240
Troubleshooting245
Index245

Related product manuals

Preview: Kioti RX6030

Preview: Kioti DK35

Preview: Kioti CK20

Preview: Kioti CK25

Preview: Kioti DK55

Preview: Kioti DK6010

Preview: Kioti DK Series

Kioti DK Series