11
9929422 R02 - 2017-2019 ACE 900 Service Manual
© Copyright Polaris Industries Inc.
11.39
BATTERY
BATTERY SPECIFICATIONS
Type
Polaris / Yuasa YIX30L
Voltage
12 Vdc
Nominal Capacity
@ 10 HR Rate
30 AH
CCA 400
Nominal Open
Circuit Voltage
12.9 Vdc or more.
Recommended
Charging Rate
5–10 hours at 3.0 AMPS
NOTE
Never attempt to open the battery. If the seal is broken,
the battery will be ruined and will fail within a few
weeks.
GENERAL BATTERY INFORMATION
WARNING
CALIFORNIA PROPOSITION 65 WARNING:Batteries,
battery posts, terminals and related accessories contain
lead and lead compounds, and other chemicals known
to the State of California to cause cancer and birth
defects or other reproductive harm. WASH HANDS
AFTER HANDLING.
WARNING
Battery electrolyte is poisonous. It contains acid!
Serious burns can result from contact with the skin,
eyes, or clothing.ANTIDOTE:External: Flush with water.
Internal: Drink large quantities of water or milk. Follow
with milk of magnesia, beaten egg, or vegetable oil. Call
a physician immediately.Eyes: Flush with water for 15
minutes and get prompt medical attention.Batteries
produce explosive gases. Keep sparks, flame,
cigarettes, etc. away. Ventilate when charging or using
in closed space. Always shield eyes when working near
batteries.Keep out of reach of children.
1. Check battery voltage with a volt/ohm meter. A fully
charged battery should be 12.8 V or higher.
2. If the voltage is below 12.6 V, the battery will need to
be recharged (see “Charging Procedure” page
11.43).
To service a Maintenance Free battery:
3. Remove battery from the vehicle (see Chapter 2).
4. Test battery with a voltage meter or load tester to
determine battery condition. This will determine the
length of time required to charge the battery to full
capacity. Refer to OCV table (see “OCV - Open
Circuit Voltage Test” page 11.42).
5. Charge the battery as recommended (see
“Charging Procedure” page 11.43).
ELECTRICAL
To Next Page
Loading...
Need help?
General
