MAINTENANCE PROCEDURES
mmo2010-009-007_b
TIGHTENING SEQUENCE
STOPPER SCREW TIGHTENING
TORQUE
10N•m±2N•m(89lbf•in ±18lbf•in)
NOTICE
Serious pulley damage
can occur if the engine stopper and
its screws are not properly installed.
Brake Fluid
Rec ommended Fluid
Use only DOT 4 brake fluid from a
sealed container. An opened container
may be contaminated or may have ab-
sorbed moisture from the air.
WARNING
UseonlyDOT4brakefluidfroma
sealed container. To avoid serious
damage to the braking system, d o
not use fluids other than the rec-
ommended one, nor mix different
fluids for topping up.
NOTICE
Brake fluid can damage
painted and plastic parts. Handle
with care. Rinse thoroughly in case
of spillage.
Brake Fluid Level
Place vehicle on a level surface.
Checkbrakefluid(DOT4)inreservoir
for proper le ve l. Add fluid (DOT 4) as
required.
WARNING
UseonlyDOT4brakefluidfroma
sealed container. To avoid serious
damage to the braking system, d o
not use fluids other than the rec-
ommended one, nor mix different
fluids for topping up.
mmo2008-008-018_a
1. Minimum
2. Maximum
3. Operating range
NOTICE
Brake fluid can damage
painted and plastic parts. Handle
with care. Rinse thoroughly in case
of spillage.
Gearbox Oil
Recommended Gearbox Oil
RECOMMENDED GEAR B OX OIL
XPS SYNTHETIC GEAR OIL (75W
140) (P/N 293 600 140)
NOTICE
The gearbox of this snow-
mobile has been developed and val-
idated using the XPS™ Synthetic
gear oil. BRP strongly recommends
the use of its XPS Synthetic gear oil
at all times. Damages caused by oil
which is not suitable for the gearbox
will not be covered by the BRP lim-
ited warranty.
98
______________
To Next Page