MAINTENANCE PROCEDURES
NOTICE
The engine of this snow-
mobile has been developed and val-
idated using the BRP XPS™ Synthe-
tic 4-stroke oil. BRP strongly recom-
mends the use of its XPS Synthetic
4-stroke oil at all times. Damages
caused by oil which is not suitable
for the engine will not be covered by
the BRP limited warrant y.
If the recommended oil is not available,
use SAE 0W40 synthetic-based oil that
meets or exceeds the requirements
for API service c lass ification SM
Engine Oil Level Verification
NOTICE
Check level before each
ride and refill if necessary. Do
not overfill. Operating the engine
with an improper level may se-
verely damage engine. Wipe off any
spill age.
Place vehicle on a level surface and
procee d a s fo llows to check oil level:
1. Start engine and let it reach its nor-
mal operating temperature. Engine
is at normal temperature when rear
radiator gets warm, indicating that
the thermostat is ope n.
2. Let engine run at idle for 30 more
seconds.
3. Stop engine.
4. O pen the LH side panel, refer to
CONTROLS, INSTRUMENTS AND
EQUIPMENT
.
5. Remove the drive belt guard, refer
to
DRIVE BELT GUARD
.
6. Remove dipstick fro m the filler tube,
then wipe it clean.
7. Completely insert dipstick in the
filler tu be .
8. Remove dipstick and c heck the oil
level. Oil level should be between
theMINandMAXmarksass
hown,
add if necessary.
1
MAX.
MIN.
mmo2009-005-027_a
1. Oil level between MIN. an d M AX.
CAUTION Engine oil can be
very hot.
WARNING
Wipe off any oil spills. Oil is highly
flammable when heated.
Exhaust System
Exhaust System Verification
The tail pipe of the muffler should be
centered with the exit hole in the bot-
tom pan. Exhaust system must be
free of rust or leaks. Make sure that all
parts are securely in place.
Check retaining springs condition and
replace if necessary.
The exha ust system is designed to re-
duce noise and to improve the total
performance of the engine. Modifica-
tion may be in vio latio n o f lo cal law s.
NOTICE
If any exhaust system
component is removed, modified
or damaged, severe engine damage
may result.
Spark Plugs
Spark plugs inspection or replacement
must be done by an authorized Ski-Doo
dealer.
96
______________
To Next Page