MAINTENANCE SCHEDULE
Maintenance is very important for keepingyourvehicle in safe operatingcondition.
Proper maintenan c e is the owner's respon sib ility. The veh icle should be serv iced
as per maintenance schedule.
The maintenance schedule does not exempt the pre-ride inspection.
WARNING
Failure to properly maintain the vehicle according to the maintenance
schedule and procedures can make it unsafe to operate.
600 H O E-TEC Models
EVERY 3 000 KM (2,000 MI) OR 1 YEAR
(WHICHEVER COMES FIRST)
Inspect heat shields
Inspect engine rubber mounts
Inspect exhaust system and check for leaks
Adjust en gi ne stopper
Visually inspect and clean drive pulley
Tighten drive pulley retaining screw to specified torque
Clean driven pulley
Adjust and align track
Inspect brake hose, pads and disk
Inspect steering mechanism
Inspect front suspension
Inspect rear suspension (including stopper straps an d slider shoes)
Lubricate rear suspension. Lubricate whenever the vehicle is used in wet conditi ons
(rain, puddles)
EVERY 6 000 KM (4,000 MI) OR 2 YEARS
(WHICHEVER COMES FIRST)
Inspect fuel pump straine
r and replace if necessary
Replace brake fluid
Inspect throttle cable
Lubricate ge a rbox
anddrivenshaftspline
90
______________
To Next Page
Loading...
