MAINTENANCE SCHEDULE
EVERY 10 000 KM (6,000 MI) OR 3 YEARS
(WHICHEVER COMES FIRST)
Replace spark plugs (must be replaced by an authorized Ski-Doo dealer)
EVERY 20 000 KM (12,500 MI)
Check valve clearance and adjust if necessary
EVERY 5 YEARS
Replace engine coolant
900 ACE Models
EVERY 3 000 KM (2,000 MI) OR 1 YEAR
(WHICHEVER COMES FIRST)
Inspect heat shields
Replace drive pulley O-rings
Visually inspect and clean drive pulley
Tighten drive pulley retaining screw to specified torque
Clean driven pulley
Checkdrivenpulleypreload
Adjust and align track
Inspect brake hose, pads and disk
Inspect steering mechanism
Inspect and lubricate front suspension
Inspect rear suspension (including stopper straps an d slider shoes)
Lubricate rear suspension. Lubricate whenever the vehicle is used in wet conditi ons
(rain, puddles)
EVERY 6 000 KM (4,000 MI) OR AT PRE-SEASON
(WHICHEVER COMES FIRST)
Change engine oil and filter
EVERY 6 000 KM (4,000 MI) OR 2 YEARS
(WHICHEVER COMES FIRST)
Replace fuel pump outlet filter
Inspect drive pulley slider shoes and ramps and replace if needed
Replace brake fluid
92
______________
To Next Page