Technogym JOG EXCITE - Page 6

JOG EXCITE: Service & Maintenance Manual - rev. 1.1
Page ii
6. TROUBLESHOOTING .......................................................................................................................................... 6.1
6.1. TROUBLESHOOTING SERVICE MENU.................................................................................................................6.2
6.1.1. Automatic Tests.................................................................................................................................6.3
6.1.1.1. I2C Device Test............................................................................................................................................................. 6.3
6.1.1.2. UpDown Test ................................................................................................................................................................6.3
6.1.1.3. Inverter Test ..................................................................................................................................................................6.3
6.1.1.4. LED Test .......................................................................................................................................................................6.4
6.1.1.5. Serial Ports Test............................................................................................................................................................. 6.4
6.1.2. Manual Test......................................................................................................................................6.4
6.1.2.1. Man. Keyboard Test...................................................................................................................................................... 6.4
6.2. THE DISPLAY FAILS TO ILLUMINATE.................................................................................................................6.5
6.3. “PRESS A KEY” MESSAGE ON THE DISPLAY ..................................................................................................6.9
6.4. “THE EQUIPMENT IS BLOCKED” MESSAGE ON THE DISPLAY .................................................................6.10
6.5. AT DRIVER ERROR.........................................................................................................................................6.11
6.5.1. Error OH ........................................................................................................................................6.13
6.5.2. Errors OC - OLi - OLm - Ot - OCH - MST - SHC .........................................................................6.14
6.5.3. Error UU ........................................................................................................................................6.15
6.5.4. Error OU ........................................................................................................................................6.16
6.5.5. Error OtM.......................................................................................................................................6.17
6.5.6. Error OLr .......................................................................................................................................6.18
6.5.7. Error PE .........................................................................................................................................6.19
6.5.8. Error EM ........................................................................................................................................6.20
6.6. TREAD BELT MOTOR IS JERKING.....................................................................................................................6.21
6.7. “GRADIENT NOT WORKING” MESSAGE ON THE DISPLAY .......................................................................6.22
6.8. THE MACHINE DOES NOT READ THE TGS.........................................................................................................6.24
6.9. THERE IS NO HEART RATE SIGNAL..................................................................................................................6.26
6.9.1. Telemetric receiver HFU................................................................................................................6.26
6.9.2. Hand sensor....................................................................................................................................6.27
6.10. THE TELEMETRIC HR SIGNAL IS INCORRECT ...................................................................................................6.29
7. DISASSEMBLY OF COMPONENTS................................................................................................................... 7.1
7.1. DISASSEMBLING THE DISPLAY .........................................................................................................................7.1
7.2. DISASSEMBLING THE CIRCUIT BOARDS OF THE DISPLAY ..................................................................................7.2
7.3. DISASSEMBLING THE KEYBOARD.....................................................................................................................7.3
7.4. DISASSEMBLING THE EMERGENCY BUTTON .....................................................................................................7.4
7.5. DISASSEMBLING THE CARDIO RECEIVER/HAND SENSOR BOARD .......................................................................7.5
7.6. DISASSEMBLING THE SENSORS.........................................................................................................................7.7
7.7. DISASSEMBLING THE READY TO RUN BOARD ..................................................................................................7.8
7.8. SMONTAGGIO MANIGLIONI ..............................................................................................................................7.9
7.9. DISASSEMBLING THE MOTOR GUARD .............................................................................................................7.10
7.10. DISASSEMBLING THE MOTOR COMPARTMENT FAN.........................................................................................7.11
7.11. DISASSEMBLING THE LIMIT SWITCH...............................................................................................................7.12
7.12. DISASSEMBLING THE ELECTRICAL BOX..........................................................................................................7.13
7.13. DISASSEMBLING THE ELECTRONICS BOARDS .................................................................................................7.14
7.14. DISASSEMBLING THE POWER SUPPLY BOX .....................................................................................................7.16
7.15. DISASSEMBLING THE TREAD BELT MOTOR .....................................................................................................7.17
7.16. DISASSEMBLING THE ELEVATION MOTOR ......................................................................................................7.18
7.17. DISASSEMBLING THE TREAD BELT GROUP......................................................................................................7.19
8. ADJUSTMENTS...................................................................................................................................................... 8.1
8.1. TENSIONING A NEW TREAD BELT .....................................................................................................................8.1
8.2. TENSIONING A USED TREAD BELT ....................................................................................................................8.2
8.3. CENTERING THE TREAD BELT...........................................................................................................................8.3
8.4. POSITION OF THE LIMIT SWITCH .......................................................................................................................8.4
9. MACHINE CONFIGURATION............................................................................................................................ 9.1
9.1. USER MENU CONFIGURATION...........................................................................................................................9.1
9.1.1. Language..........................................................................................................................................9.1
9.1.2. Distance............................................................................................................................................9.2