Problem
Possible cause
Remedy
Page
Discharge warning
Fuse blown
Check "CHARGE" and "GAUGE"
li
ght does not light
fuses
with ignition ON and
Light burned out
Replace light
and engine not
Wiring connections loose
Tighten loose connections
running
IC regulator faulty
Replace IC regulator
CH-8
Discharge warning
Drive belt loose or worn
Adjust or replace drive belt
CH-4
li
ght does not go
Battery cables loose, corroded or worm
Repair or replace cables
out with engine
running (battery
Fuse blown
Check "ENGINE" fuse
requires frequent
Fusible link blown
Replace fusible link
recharging)
IC regulator or alternator faulty
Check charging system
CH-5
Wiring faulty
Repair wiring
CH-2
CHARGING SYSTEM —
Precautions, Troubleshooting
PRECAUTIONS
1.
Check that the battery cables are connected to the
correct terminals.
2.
Disconnect the battery cables when the battery is
given a quick charge.
3.
Do not perform tests with a high voltage insulation
resistance tester.
4.
Never disconnect the battery while the engine is run-
ning.
TROUBLESHOOTING
ProCarManuals.com
To Next Page
Loading...
