CaptiveAire HVLS - Page 35

76 pages

Save Page as PDF

To Next Page

To Next Page

To Previous Page

To Previous Page

Loading...

35

Figure 31 - VFD Wiring (240 Volt Single-Phase)

Figure 32 - VFD Wiring (120 Volt Single-Phase)

Table of Contents

Table of Contents2
Warranty3
- HVLS Extended Warranty3
- Warranty Conditions4
Installation5
- Mechanical5
  - Main Control Enclosure Installation5
  - Site Preparation - Controls5
- Hardware Torques6
  - Remote Room Sensor/Hmi Installation7
  - Room Temperature Sensor7
- HVLS Fan Clearance8
  - Fan Located below HVAC Discharge or Intake8
  - Fan Located at or above HVAC Discharge or Intake9
  - Fan Located Near Lighting Sources9
- Site Preparation - Fan11
- Fan Mounting Configurations11
- I-Beam Mount12
- Concrete Beam Direct Mount13
- Concrete Multi-Beam Mount14
- Wood Beam Direct Mount15
- Open Web Steel Joist Mount(S)17
  - Direct Beam Mount17
  - Installing Fan between OWSJ18
- Mounting between OWSJ19
- Purlin Mount23
- Installing Pivot Mount Assembly25
- Tube Assembly26
- Leveling Pivot Assembly27
- Hub Assembly28
- Mounting Fan to Extension29
- Guy Wire30
  - Clamp Installation30
  - Guy Wire Installation30
- Blade Installation32
- Electrical33
- High Voltage Wiring34
- VFD Wiring34
- Variable Frequency Drive (VFD)36
  - VFD Installation37
  - Input AC Power37
  - VFD Output Power37
  - VFD Programming38
  - Actech Smv Vfd39
  - Low Voltage Wiring40
Operation41
- Smart Control Functionality41
  - Summary of Fan Control41
  - Automatic Mode41
- Scheduling43
- Manual Mode43
- Start-Up Procedure45
  - Start-Up Procedure - Fans45
- Start-Up Procedure - Smart Control45
- Manual Mode Startup47
- Automatic Mode Startup48
HMI Configuration49
- General Overview49
Editing HMI Number and Contrast49
- Input Simulation49
HMI Configuration Details50
HMI Menu System Overview51
- HMI Menu Tree51
ECPM03 Configuration52
- General Overview52
- Product Mode52
ECPM03 Menu System Overview53
- ECPM03 Configuration Details53
- ECPM03 Menu Tree56
ECPM03 Board57
- Connector Descriptions57
Building Management System60
Emergency Shutdown Interlock60
- Manual/Auto Mode from HMI (Lowest Priority)60
- Low Voltage BMS Interlock61
- High Voltage BMS Interlock61
Network62
- Bacnet62
- Device Instance, MAC Address, Baud Rate63
- Changing the IP Address64
- Lonworks65
Direct Digital Control (DDC)66
Troubleshooting70
- VFD Fault List71
- HMI Fault List72
Maintenance73
General Maintenance73
Every 3 Months73
Months after Startup73
Every 12 Months74
Every 36 Months74
Maintenance Logging and Alerts74
Start-Up Documentation76

Related product manuals

Preview: CaptiveAire DI-PSP

CaptiveAire DI-PSP