FLOWBIRD CWT Compact S4 Touch

To Next Page

To Previous Page

Page 83CWT Compact S4 Touch Installation & Maintenance Manual for CWT 1.0-0Issue 3

Corrective maintenance

Figure 50, The dowel pin should mate with the locking

latches

Check that the DIP switch setting corresponds to the E-lock position in the

terminal.

Main Page

Table of Contents3
Aprovals6
Introduction6
About this Manual6
Available Formats7
List of Major Changes7
Target Audience7
Structure of this Book7
References8
Terminology8
Safety10
High Voltage10
Batteries11
Back-Up Battery Holder on CPU Board11
Short-Circuit Risk12
Caustic Acid12
Risk of Explosion12
Disposal13
LCD Display13
Heavy Lifting13
Risk of Tipping13
ESD Protection14
Product Description15
Means of Payment16
Coin System17
Anti-Pin Module18
Coin Verifier21
Escrow23
Coin Handling Board24
Coin Box25
Card Readers26
Touch Enabled Colour Display27
Data Communication28
Print System28
Gebe GTP4672 Thermal Printer29
Sensors31
Printer Mounting32
Paper Supply33
Preprinting on Printer Media33
Black Mark Location34
The Service Menu35
Mechanical Design35
General35
Product Label36
Inside the Cabinet36
Inside the Pedestal38
COIN BOX Vault39
Door Locks40
Mechanical Locks40
Electronic Locks41
Door-Open Sensors43
Heating System44
Power Supply44
Power Control44
Battery Charging by Solar Power45
Battery Charging by Mains Power46
Administrative Tools46
CWT Compact Interconnections47
CPU Board Version 0501-E0150 Rev I47
Terminal Measurements51
Installation51
Site Preparations51
Minimal Site Dimensions & Mounting Holes51
Solar Power Positioning52
Placing the Terminal on an Existing Concrete Foundation53
Pouring a New Concrete Foundation54
Power Supply55
Installing the Terminal56
Mounting the Pedestal in Its Foundation56
Mounting the Cabinet on Top of the Pedestal57
Installing the Battery57
Connecting to the Mains Power Grid58
Installing a Modem58
Loading Paper in a Gebe Printer61
Installing the Coin Box62
Program Loading62
Changing the Settings of the Terminal63
Daily Operation63
Changing and Emptying the Coin Box63
Paper Refill65
Preventive Maintenance65
Batteries65
Gebe Printer GTP467267
Print Head67
Cleaning70
Testing71
Coin Handling Unit71
Card Readers72
Chip-Card Reader72
Hybrid Card Reader72
Display Module73
Cabinet Door Display Window73
Cabinet73
Solar Panel74
Corrective Maintenance74
Lead Battery Replacement75
CPU Board Lithium Cell Replacement75
Printer Replacement76
Coin Unit Replacement76
Coin Verifier Replacement77
Card Reader Replacement78
Display Module Replacement78
Connecting the Display to the CPU Board80
Cabinet & Pedestal81
Cabinet & Pedestal Door Replacement81
E-Lock Replacement82
Changing the CWT Compact Software and Firmware84
Appendix85
CWTC S4 Touch Door85
CWTC S4 Touch Display Panel85
CWTC S4 Touch Display Unit86
Keyword Index87

FLOWBIRD CWT Compact S4 Touch - Page 83

Table of Contents