Garmin G1000 - System Maintenance Manual

To Next Page

ALT

2992

1000

300

100

150

200

250

1013

190-00716-01 February 2014 Revision 4

G1000 / GFC 700

System Maintenance Manual

Hawker Beechcraft

Model 300/B300 Series King Air

Contains Instructions

For Continued Airworthiness

For STC SA01535WI-D

Main Page

Table of Contents5
Introduction13
Content, Scope, Purpose13
Table 1-1, G1000 System Software Version13
Organization15
Definitions/Abbreviations16
Publications17
Table 1-2, Required Documents17
Revision and Distribution18
Table 1-3, Reference Publications18
System Description19
Equipment Descriptions19
Figure 2-1 Display Units20
Figure 2-2, Audio Panel21
Figure 2-3, AFCS Controller21
Figure 2-4, FMS Controller22
Figure 2-5, Transponder22
Figure 2-6, GIA Unit23
Figure 2-7, GEA Unit24
Figure 2-8, Air Data Computer25
Figure 2-9, OAT Probe25
Figure 2-11, Magnetometer26
Figure 2-12, GDL 69A Datalink27
Figure 2-13, GDL 59 Wi-Fi Datalink27
Figure 2-14, GSR 56 Satellite Receiver28
Figure 2-15, GSD 41 Data Concentrator28
Figure 2-17, GTS Traffic Processor29
Figure 2-20, GSA 9000 / GSM 910031
Figure 2-21, GRA 5500 Radar Altimeter31
G1000 Optional Interfaces32
Electrical Power Distribution33
Figure 2-22, 300/B300 Electrical Distribution (Post G1000 STC)34
Figure 2-23, G1000 Component Power Sources35
Electrical Load Utilization36
Table 2-1, Electrical Loads36
Pitot/Static System40
Figure 2-24, Pitot/Static System (Post G1000 STC)40
Shield Block Grounds41
G1000 /Gfc700 Block Diagram41
Figure 2-25, G1000/GFC 700 Block Diagram41
G1000 Control & Operation43
Gdu 1040A and Gdu 1500 Displays43
Figure 3-1, GDU 1040A Control Interface43
Figure 3-2, GDU 1500 Control Interface44
Figure 3-3, G1000 Softkeys44
Gcu 477 - Mfd Controller45
Gmc 710 - Afcs Controls45
Figure 3-4, MFD Controls (GCU 477 Shown)45
Figure 3-5, AFCS Controls (GMC 710 Shown)45
Gma 1347D Audio Panel46
Figure 3-6, GMA 1347D Controls46
G1000 Normal Mode47
Figure 3-7, Normal Mode47
Reversionary Mode48
Figure 3-8, Automatic Reversion with MFD Failure48
Figure 3-9, Manual Reversion with Pilot PFD Failure48
Configuration Mode Overview49
Figure 3-10, SET>ACTV Diagram50
Figure 3-11, Loss of Communication51
Figure 3-12, Configuration Status51
Figure 3-13, Data Transmission Indicators51
G1000 / Gfc 700 Software Information54
Figure 3-14, G1000 LRU Configuration File Storage59
Figure 3-15, GRS/GDC Configuration Settings Storage60
G1000 Software/Configuration Procedure61
Figure 3-16, Software/Configuration Overview61
Figure 3-17, Airframe Options63
Figure 3-18, Propeller Options63
Figure 3-19, Configuration/Software Load Page64
Non-Garmin TAS/TCAS I Traffic System Option Configuration66
Gts 820/850 Traffic System Configuration67
Gts Processor68
Gtx 33/33D Configuration69
Gtx 3000 Configuration70
GDL 59 Wi-Fi Data Link Option Configuration71
GSR 56 Satellite Receiver with GDL 59 Wi-Fi Data Link Option Configuration72
GSR 56 Satellite Reciever Stand-Alone Option Configuration73
GRS 77 AHRS Software/Configuration74
GRS 7800 AHRS Software/Configuration75
GWX 68 Software/Configuration76
GWX 70 Software/Configuration77
GMU 44 Software/Configuration78
Taws-A Support Configuration79
TAWS-A Voice no Callout Option Configuration80
Taws-A Voice Callout Option Configuration81
Adf Option Configuration82
Dme Option Configuration83
Rad Alt Option Configuration84
Non-Garmin TCAS II Traffic System Option Configuration87
Lightning System Option Configuration88
Lightning System Option Configuration Load Confirmation89
Figure 3-20, Stormscope Configuration Page89
Figure 3-21, Stormscope Configuration89
Esp Support Option Configuration91
Pots Handset Configuration92
Flight Data Recorder Option Configuration93
Table 3-1, Flight Data Recorder Parameters93
Flitecharts Configuration95
Optional Chartview Enable95
Standard Taws-B Enable96
Optional Taws-A Enable97
Supplemental Database Loading98
Figure 3-22, Supplemental Database Synchronization98
Optional Svs/Pathways Enable99
Optional Esp Enable100
Optional Search and Rescue Enable101
Optional Garmin Tcas I Enable (from Gts 825 to Gts 855)102
Optional Garmin Tcas II Enable (from Gts 825 to Gts 8000)103
Aircraft Registration Number Entry104
Figure 3-23, Aircraft Registration104
Gdl 69 Alternate Antenna Location Configuration106
Figure 3-24, GDL 69 Cable Loss106
Figure 3-25, GDL 69 Cable Loss Configured106
BLR Winglet Option (Model 300 Only)107
Splash Screen Loading108
Navigation Database Loading109
Figure 3-26, Navigation Database Synchronization109
Configuration of Navigation Map for Traffic System111
Clearing Default User Settings111
Servicing Information114
Maintenance Intervals116
Table 4-1, Maintenance Intervals116
Table 4-2, Discontinued Maintenance Intervals122
Visual Inspection123
Table 4-3, Nose Section Visual Inspection Procedure123
Table 4-4, Nose Avionics Compartment Visual Inspection Procedure123
Table 4-5, Pilot's Compartment Visual Inspection Procedure124
Table 4-6, Instrument Panel G1000 Equipment Visual Inspection Procedure124
Table 4-7, Cabin Area Visual Inspection Procedure126
Table 4-8, Rear Fuselage and Empennage Visual Inspection Procedure127
Electrical Bonding Test128
Table 4-9, Lightning Strike Inspection Procedure128
Grs 77 or Grs 7800 Earth Magnetic Field Updates131
Gsa 80 Greasing Procedure131
Flaps-In-Motion Discrete Input Check132
Figure 4-1, GIA I/O Page132
Figure 4-2, Discrete Valid/Invalid Indications132
Gsm 86 Slip Clutch Torque Check Procedure133
Figure 4-3, GFC Status Page133
Table 4-10, Measured Torque134
G1000 Redundant Connection Check135
Engine Data Check138
Table 4-11, Engine Data Check Test Equipment138
Table 4-12, ITT Indication Test Points138
Figure 4-4, Ambient Temperature Conversion Chart139
Table 4-13, Torque Indication Test Points139
Trim Annunciator Check140
G1000 Miscompare Checks142
Gia Cooling Fans Operational Check143
Gdu Cooling Fans Operational Check143
Standby Battery Periodic Checks144
Figure 4-5, Standby Battery144
Table 4-14, Standby Battery Required Equipment144
Figure 4-6, Power Supply Connection146
Rudder Boost Operational Check147
Exterior Skin Inspection Around Antennas147
Figure 4-7, Exterior Skin Inspection Around Antennas148
Troubleshooting149
Figure 5-1, aux - System Status Page149
G1000 Alerting System150
Figure 5-2, Alerts & Annunciations150
Figure 5-3, ADVISORY Softkey Annunciation150
System Annunciations153
Figure 5-4, System Annunciations153
300/B300 Specific Alerts174
Taws Troubleshooting175
Synthetic Vision and Pathways Troubleshooting176
Table 5-1, SVS Troubleshooting176
Table 5-2, SVS-Related Alert Messages176
Gfc 700 Afcs Troubleshooting177
Figure 5-5, AFCS Annunciation Field177
Table 5-3, AFCS Annunciation Troubleshooting178
Table 5-4, AFCS General Troubleshooting179
Figure 5-6, GFC Status Page180
Backup Communications Path Checks192
Gdu 104X Troubleshooting193
Gdu 104X Alerts195
Gia 63 Troubleshooting203
Gia Alert Messages205
Gea Troubleshooting212
Gtx Troubleshooting213
Gdl 69A Troubleshooting214
Grs 77 or Grs 7800 and Gmu 44 Troubleshooting216
Figure 5-7, Magnetometer Interference Test219
Table 5-5, Magnetometer Interference Test Sequence220
Gdc 7400 Troubleshooting222
Gwx 68 Gwx 70 Troubleshooting223
Gmc 710 Troubleshooting224
Gcu 477 Troubleshooting225
Software/Configuration Troubleshooting226
Mating/Backplate Connectors228
Figure 5-8, GIA 63W Backplate Connectors228
Figure 5-9, GEA 71 Backplate Connectors229
Figure 5-10, GMA 1347D Backplate Connectors229
Figure 5-11, GTX 33/33D Backplate Connectors229
Figure 5-12, GTX 3000 Connector230
Figure 5-13, GDU 1040A/1500 Mating Connector (P10401 or P15001)230
Figure 5-14, GRS 77 Mating Connector (P771)230
Figure 5-15, GRS 7800 Mating Connector (P78001)230
Figure 5-16, GDC 7400 Mating Connector (P74001)231
Figure 5-17, GDL 69A Mating Connector (P69A1)231
Figure 5-18, GCU 477 Mating Connector (P4751)231
Figure 5-19, GMC 710 Mating Connector (P7101)231
Figure 5-20, GWX 68 Mating Connector (P681)231
Figure 5-21, GWX 70 Backshell Connector (P751)232
Figure 5-22, GTS 820/850 Mating Connectors232
Figure 5-23, GTS Processor Connector (P8001)232
Figure 5-24, GPA 65 Mating Connector (P651)232
Figure 5-25, Signal Conditioner Mating Connector (PVIB1)233
Figure 5-26, GDL 59 Backplate Connector (P591)233
Figure 5-27, GSR 56 Backplate Connector (P561)233
Figure 5-28, GSD 41 Backplate Connector (P411)233
Figure 5-29, GSA 9000 Mating Connector (P90001)233
Figure 5-30, GRA 5500 Connector (P55001)234
Standby Attitude Indicator Troubleshooting235
Standby Airspeed Indicator Troubleshooting235
Standby Altimeter Troubleshooting236
Gdl 59 Troubleshooting236
Gsr 56 Troubleshooting237
Gts 820/850 Troubleshooting237
Gts Traffic Processor Troubleshooting238
Equipment Removal & Installation241
Gdu 1040A and Gdu 1500242
Gma 1347D Audio Panel242
Gia 63W Integrated Avionics Units243
GEA 71 Engine/Airframe Unit243
Gtx 33( ) or Gtx 3000 Transponder244
Gdc 7400 Air Data Computer244
Gtp 59 Oat Probe245
Grs 77 or Grs 7800 Ahrs245
Gmu 44 Magnetometer246
Gdl 69A247
Gsa 80 and Gsa 9000 Servos247
Gsm 86 and Gsm 9100 Servo Gearbox248
Figure 6-1, GSA 80 Servo Gear248
Figure 6-2, GSM 9100 O-Ring248
Gcu 477249
Gmc 710249
Gwx 68 or Gwx 70249
Configuration Modules250
Figure 6-3, Configuration Module Installation250
Figure 6-4, GRS 7800 Configuration Module Installation251
Table 6-2, GRS 7800 Configuration Module Parts251
Gea 71 Backshell Thermocouple Removal & Replacement253
Figure 6-5, GEA Backshell Thermocouple253
Table 6-3, Thermocouple Kit (011-00981-00)253
Gps/Waas Antennas254
Diversity Transponder Antenna254
Iridium Antenna255
Wi-Fi Antenna255
Signal Conditioners255
Instrument Panel Switch /Annunciator (Prop Synch and Standby Battery )256
Emergency Frequency Switch/Annunciator256
Standby Battery257
Standby Airspeed Indicator257
Standby Altimeter257
Standby Attitude Indicator258
Gia Cooling Fans259
Gdu Cooling Fans260
Gts 820/850 Traffic Unit260
Gpa 65 Pa/Lna Unit261
Ga 58 Traffic Antennas262
GDL 59 Wi-Fi Datalink262
Gsr 56 Satellite Receiver263
Gsd 41 Data Concentrator263
Gts Traffic Processor264
Gra 5500 Radar Altimeter264
G1000 Equipment Configuration & Testing265
Gdu 1040A/1500 Mfd & Pfd265
Figure 7-1, G1000 Normal Mode Check266
Gma 1347D Audio Panel267
Figure 7-2, Marker Beacon Symbology268
Gia 63W Integrated Avionics Unit270
Figure 7-3, aux - GPS STATUS Page (MFD)270
GEA 71 Engine/Airframe Unit273
Figure 7-4, Normal Engine Instrument Markings (MFD)273
Table 7-1, Fuel Flow Indication Test Equipment274
Table 7-2, Fuel Flow Test Points274
Table 7-3, Oil Pressure Indication Test Equipment275
Table 7-4, Oil Pressure Test Points275
Gtx 33( ) or Gtx 3000 Transponder276
Figure 7-5, Aircraft Registration276
Gdc 7400 Air Data Computer277
Table 7-5, Air Data System Test279
Table 7-6, Vertical Speed Table281
Grs 77 or Grs 7800 Ahrs / Gmu 44 Magnetometer282
Table 7-7, Required GRS/GMU Calibrations283
Figure 7-6, Engine Run-Up Test Page288
Figure 7-7, Normal Mode AHRS Check289
Gdl 69A XM Data Link290
Gsa 80/9000 Servos290
Gcu 477 Fms Controller291
Gmc 710 Afcs Controller293
Gwx 68 or Gwx 70 Weather Radar294
Non-Garmin Traffic System (TAS/TCAS I) Functional Check295
Non-Garmin Traffic System (TCAS II) Functional Check296
Lightning System Functional Check297
Taws Functional Check299
Flitecharts Functional Check302
Chartview Functional Check303
Safetaxi Functional Check304
Dme Functional Check305
Adf Functional Check306
Gra 5500 Radar Altimeter Functional Check306
Non-Garmin Radar Altimeter Check306
Weight on Wheels and Low Speed Awareness Band Check307
Figure 7-8, Low Speed Awareness Band Symbolization307
Rvsm Checks308
Figure 7-9, RVSM Required Avionics308
Figure 7-10, RVSM Critical Region309
Figure 7-11, Dial Indicator311
Figure 7-12, Static Port Measurement311
Figure 7-13, Static Port Measurement Locations312
Figure 7-14, Static Port Measurement Log312
Table 7-8, In-Flight Altitude Hold Performance Test313
Esp Functional Check314
Gts Traffic System Functional Check317
Figure 7-15, GTS 8XX GND TEST Softkey317
Activation of Garmin Connext320
GDL 59 Wi-Fi Data Link Functional Check322
Gsr 56 Satellite Receiver Functional Check323
Figure 7-16, GSR56 Configuration Page323
Figure 7-17, AUX-TELEPHONE Page323
Search and Rescue Functional Check324
System Return to Service Procedure325
Backup Path System Testing326
Figure 8-1, GDU Data Verification (ARINC 429)331
Figure 8-2, GIA Data Verification (ARINC429/RS-232)332
Figure 8-3, GIA Data Verification (RS-485)333
Gfc 700 Ground Checkout334
Figure 8-4, Pre-Flight Test334
Maintenance Records339

Garmin G1000 - System Maintenance Manual

Table of Contents

Other manuals for Garmin G1000

Related product manuals