HydraMaster Boxxer 318 - Page 52

6-3: Electrical System
Wiring Diagram - Figure 6-2.
View 1 of 3
7025 Rev. E
87
87a
86
85
30
TR7TR5TR6
TR3 TR4
TC-1
TR1 TR2
CONTROLLER
TEMPERATURE
TR8
13 (PUR/WHT)
27 (BLK)
28 (RED)
29 (BLU)
1 2 3 4 5 6
25 (BLK)
26 (WHT)
HIGH TEMP SOLENOID LIGHT (GRN) L-2
3 (YEL)
3(YEL) TO ENGINE STOP LUG
(SHEET 1)
30 (WHT)
9 (WHT) TO ENGINE GROUND LUG - 14 GA (SHEET 1)
35 (WHT/BLK) TO PUMP IN PUMP PMP-1 (SHEET 1)
32 (WHT/GRN) TO FUEL PUMP PMP-2 (SHEET 1)
18 (BLK/WHT) TO HOUR METER- HI-1 (SHEET 3)
TO CONTROLLER SENSOR- SW-5 (SHEET 3) 26(WHT) 20 GA
TO CONTROLLER SENSOR- SW-5 (SHEET 3) 25(BLK) 20 GA
TO HARNESS P5-D (SHEET 1) 13(PUR/WHT)
TO THERMOSTAT
TS-1
(SHEET 3)
(RED) 20 GA
23(PNK) TO HIGH TEMP SHTDN
SWITCH SW-4 (SHEET 3)
23 (PNK)
19 (BLK)
19(BLK) TO LOW WATER ENGINE
STOP FS1- 20 GA (SHEET 1)
37 (RED) TO FUEL PUMP PMP-2 (SHEET 1)
20 (BLK) TO LOW WATER ENGINE STOP FS1 - 20 GA (SHEET 1)
20 (BLK)
31 (GRY) TO PUMP IN SWITCH SW2 -#2 (SHEET 3)
FUSE
FU-1
FUSE
FU-2
34 (BRN) 14 GA TO APO SWITCH SW3- #3 (SHEET 3)
7 (ORG) TO SOL 1-BATT (SHEET 1)
(ORG)
B-10
24 (PNK) TO HIGH TEMP SHTDN SWITCH SW-4 (SHEET 3)
B-11
B-13
B-12
(BLK)
(RED) 20 GA
(BLK) 20 GA
22 (WHT/RED)
30 (WHT)
22 (WHT/RED)
B-9
(ORG)
17 (WHT/ORG) TO HOUR METER- HI-1 (SHEET 3)
ENGINE SHUTDOWN
RELAY
CR-1
TERMINAL BLOCK- TB-1
21 (WHT/RED)
33 (RED)
1 (RED) 16 GA TO CARB SOLENOID V-1 (SHEET 1)
38 (BLK) 16 GA TO SW1-2 (SHEET 3)
6 (ORG) TO SOL 1-BATT (SHEET 1)
35 (ORG) 16 GA. TO IGNITION SW1-1 (SHEET 3)
B-14
B-15
25 A
25 A
D
C
B
A
B
C
D
1 2 3
4 5
6
7
8
8
7
6
5
4
3
2
1
E
F
E
F
A
WIRING DIAGRAM - BOXXER
318
E
REV
7025
10/15/2007
10/15/2007
10/15/2007
CODE:
SIZE
C
11015 47th Avenue West,
Mukilteo, Washington 98275
PROPRIETARY INFORMATION
DRAWING NUMBER
SHEET 2 OF 4
APPVD
CHECKED
DRAWN
B.R.T.
C.I.R
B.R.T.
- - -
BY DATE
000-179-009
PART NUMBER