Polaris Hawkeye - Page 17

MAINTENANCE
2.5
Item Maintenance Interval
(whichever comes first)
Remarks
Hours Calendar Miles
(Km)

E
Fuel system 100 H 12M
1000
(1600)
Check for leaks at tank cap, lines, fuel valve, filter,
pump, carburetor, replace lines every two years

E
Fuel Filter 100 H 12M
1000
(1600)
Replace yearly

Radiator
(if applicable)
100 H 12M
1000
(1600)
Inspect; clean external surfaces

Cooling hoses
(if applicable)
100 H 12M
1000
(1600)
Inspect for leaks

Engine mounts 100 H 12M
1000
(1600)
Inspect
Exhaust muffler /
pipe
100 H 12M
1000
(1600)
Inspect

E
Spark plug 100 H 12M
1000
(1600)
Inspect; replace as needed

E
Ignition Timing 100 H 12M
1000
(1600)
Inspect

Wiring 100 H 12M
1000
(1600)
Inspect for wear, routing, security; apply dielectric
grease to connectors subjected to water, mud, etc.

Clutches (drive
and driven)
100 H 12M
1000
(1600)
Inspect;clean; replace worn parts

Front wheel
bearings
100 H 12M
1000
(1600)
Inspect; replace as needed
 Brake fluid 200 H 24M
2000
(3200)
Change every two years
Spark arrestor 300 H 36M
3000
(4800)
Clean out
E Idle Speed - Adjust as needed
 Toe adjustment - Inspect periodically; adjust when parts are replaced


Auxiliary brake Pre- Ride Inspect daily; adjust as needed
Headlight aim - Adjust as needed
Perform these procedures more often for vehicles subjected to severe use.
E Emission Control System Service (California)
 Have an authorized Polaris dealer perform these services.