MAINTENANCE
2.9
HAWKEYE HANDLEBAR COMPONENT LOCATIONS
MAINTENANCE QUICK REFERENCE
* More often under severe use, such as operated in water or under severe loads.
1 Semi-annually or 50 hours of operation (refer to Maintenance Schedule for additional information)
2 Annually or 100 hours of operation (refer to Maintenance Schedule for additional information)
3 Grease conforming to NLGI No. 2, such as Polaris Premium All Season Grease, Conoco Superlube M or Mobilegrease Special.
III. # Item Lube Rec. Method Frequency*
1
Engine Oil Polaris 0W-50
Synthetic
Add oil to proper level.
Change after 1st month (25
hours), 50 hours thereafter;
Change more often (25 hours)
in severe duty conditions, or
short trip cold weather
operation.
2 Transmission
Polaris AGL
Lubricant
See procedure. Change annually2
3Brake Fluid
Polaris DOT 3 Brake
Fluid
Fill master cylinder reservoir
to indicated level inside
reservoir.
As required. Change fluid
every 2 years.
4
Rear
Gearcase
Polaris ATV Angle Drive
Fluid
Drain and refill with pre-
measured amount of
lubricant.
As required*
5
A-Arm
Bushings
Polaris All Season
Grease 3
Locate grease fitting on
swing arm and grease with
grease gun.
Semi-annually 1
Throttle
Front Brake
Choke
Indicator Lights
Ignition/Start Key
Light Control
& Run Switch
Reverse
Override
(if applicable)
Speedo
To Next Page
Loading...
Need help?
General
