131
SJ1044 TH, SJ1044 THS, SJ1056 TH, SJ1056 THS, SJ1256 THS
230790ABA
10 Hour or Daily Routine Maintenance Section 5 – Procedures
5.2-6 Drain Fuel/Water Separator
WARNING
Diesel fuel is flammable and may cause death
or serious injury. Shut down engine and do not
smoke while draining fuel/water separator.
1. Ensure engine is shut down & telehandler is
parked on a firm level surface.
2. Prepare a container for draining the fuel/water
separator and place it under the separator.
3. Open drain reservoir and allow approximately one
cup of fuel and any collected sediment to drain
into the container. Refer to the Figure below.
Fuel/Water
Separator
Drain
Valve
Figure 08 Fuel/Water Separator
4. Close the drain then dispose of the collected
liquid in an environmentally safe manner.
NOTE
Refer to your local/national environmental
regulations on how to dispose of used fuels and
other dangerous liquids.
5.2-7 Fuel Tank
WARNING
Do not allow fuel tank to become completely
empty. If tank is allowed to empty completely, the
entire fuel system will require bleeding.
1. Check fuel gauge inside operator’s cab.
2. Ensure fuel is at an appropriate level before the
start of each work shift.
3. Add diesel fuel as required.
NOTE
Refer to Operating Manual for refueling
procedure.
5.2-8 Check Parking Brake
1. Check the park brake operation daily or every 10
hours of service.
NOTE
Refer to “Park Brake Test Procedure” in Section 2
of Operating Manual.
5.2-9 Check Tire Pressure and Condition
1. Check the tire pressure when cold and inflate to
the recommended pressure. Refer to Operating
Manual for tires and tire pressure specifications.
WARNING
Do not over-inflate. Tire may explode causing
death or severe injury.
2. Remove wheel from telehandler to fill the
tire whenever pressure is below 80% of the
recommended pressure.
3. Place tire in a cage and inflate using a clip-on
chuck and a remote tire pressure gauge.
To Next Page
Loading...
