Maintenance
Machine Disposal and Decommissioning 8.12
87
[en-US] | 02/2023 | 5100065071 | LTV 4L/6L | Operator’s Manual
KDW 1003 and KDW 702 Service Intervals
Service Item
Every X Hours (Frequency)
10 50 100 300 500
1000
(1 year)
2000
(2 years)
4000
(4 years)
Remove fuel tank sediment X
Replace rubber intake hose X
Check/replace fuel lines X
Change radiator coolant X
Replace radiator hoses and clamps X
Replace timing belt X
Oil spec
2)
0W-40, full synthetic CJ4
1) Engine oil service interval decreases when not using ultra low sulfur diesel. The oil change interval is 1000 hours on standard units and 3000
hours on extended service interval units.
2) Refer to Kohler engine manual.
8.12 Machine Disposal and Decommissioning
Introduction
This machine must be properly decommissioned at the end of its service life.
Responsible disposal of recyclable components, such as plastic and metal,
ensures that these materials can be reused—conserving landfill space and
valuable natural resources.
Responsible disposal also prevents toxic chemicals and materials from
harming the environment. The operating fluids in this machine, including
fuel, engine oil, and grease, may be considered hazardous waste in many
areas. Before decommissioning this machine, read and follow local safety
and environmental regulations pertaining to the disposal of construction
equipment.
Preparation
• Move the machine to a protected location where it will not pose any
safety hazards and cannot be accessed by unauthorized individuals.
• Ensure that the machine cannot be operated from the time of final shut-
down to disposal.
• Drain all fluids, including fuel, engine oil, and coolant.
• Seal any fluid leaks.
Disposal
• Disassemble the machine and separate all parts by material type.
• Dispose of recyclable parts as specified by local regulations.
• Dispose of all non-hazardous components that cannot be recycled.
• Dispose of waste fuel, oil, and grease in accordance with local environ-
mental protection regulations.
8
To Next Page
Loading...
Need help?
General
