Binder UF V - Page 109

To Next Page

To Previous Page

UF V (E3) 03/2019 Page 109/116

DOMINIQUE DUTSCHER SAS

Main Page

Table of Contents2
Safety6
Legal Considerations6
Structure of the Safety Instructions6
Signal Word Panel7
Safety Alert Symbol7
Pictograms8
Word Message Panel Structure8
Localization / Position of Safety Labels at the Chamber9
Type Plate10
General Safety Instructions on Installing and Operating the Chamber11
Intended Use13
Operating Instructions13
Measures to Prevent Accidents14
Chamber Description15
Chamber Overview17
Door Lock and Controller Housing19
Operating the Numpad (Option "Door Access System")20
Operating the Electromechanical Door Locking (Option "Door Access System")20
Main Power Switch21
Chamber Rear22
Doors23
Outer Door23
Compartment Doors23
Drain Well for Condensate During Defrosting (Option)24
Completeness of Delivery, Transportation, Storage, and Installation25
Unpacking, and Checking Equipment and Completeness of Delivery25
Guidelines for Safe Lifting and Transportation26
Moving the Freezer Inside a Building26
Transport Outside a Building27
Storage28
Location of Installation and Ambient Conditions28
Installation and Connections30
Operating Instructions30
Spacers for Rear Wall Distance30
Adjustable Shelves31
Connections of Cooling Water for Chambers with Water Cooling (Option)33
Connection of Cooling Water Outlet for Water Cooling33
Connection of Cooling Water Inlet for Water Cooling34
Connection Kit for Cooling Water34
Electrical Connection36
Advanced Voltage Booster (Option)36
Functional Overview of the Rd4 Chamber Controller37
Menu Structure of the Controller and Access Levels38
Start up39
Preset Factory Parameters39
Behavior after Turning on the Chamber39
Temperature Set-Point Entry40
Placing Samples in Storage in the Freezer41
Setting Special Controller Functions42
Password43
Password Request43
Assign and Modify a Password43
Assign and Modify the User Password44
Assign and Modify the Admin Password44
Performance During and after Power Failure and Shut down45
Safety Controller (Temperature Safety Device)45
Setting the Safety Controller Mode46
Setting the Safety Controller Value46
Message and Measures in the State of Alarm47
Function Check47
General Controller Settings48
Selecting the Controller's Menu Language48
Selecting the Temperature Unit48
Setting the Current Date49
Setting the Current Time50
Function "Language Selection at Restart50
Setting the Chamber Address51
Display Brightness51
Tolerance Range and Alarm Delay Settings52
Setting the Delay Time for Door Open Alarm52
Setting the Delay Time for Tolerance Range Alarm52
Setting the Temperature Tolerance Range53
Alarm Functions54
Alarm Messages54
Information Messages56
Activating / Deactivating the Audible Alarm (Alarm Buzzer)56
Required Actions in Case of an Alarm57
Safety Controller Temperature Alarm57
Temperature Tolerance Range Alarm (too High and too Low Temperature)57
Door Open Alarm58
Power Failure Alarm (Chamber with Option "Battery-Buffered Alarm System")58
Messages on the Battery Management System (Chamber with Option "Battery-Buffered Alarm System")59
Messages Referring to Temperature Sensor Failure60
Messages Referring to CO Emergency Cooling (Option CO Emergency Cooling)61
Zero-Voltage Relay Alarm Output62
Ethernet Network Settings63
Showing the Network Settings63
Showing the Chamber's MAC Address63
Showing the IP Address64
Showing the Subnet Mask64
Showing the Standard Gateway64
Showing the DNS Server Address65
Showing the DNS Chamber Name65
Changing the Configuration of the Network Settings65
Selecting the Type of IP Address Assignment (Automatic / Manual)66
Selecting the Type of Assignment of the DNS Server Address (Automatic / Manual)66
Assigning the IP Address66
Setting the Subnet Mask67
Setting the Standard Gateway68
Assigning the DNS Server Address68
Access Codes (Option "Door Access System")69
Assigning the Access Codes69
Opening the Chamber Door with the Access Code70
Data Recorder71
Recorded Data71
Storage Capacity71
Setting the Storage Rate for the "DL1" Recorder Data72
Deleting the Data Recorder72
Usb-Menu: Data Transfer Via Usb Interface73
Connecting the USB Stick73
Import Function73
Export Functions74
Ongoing Data Transfer74
Error During Data Transmission75
Removing the USB Stick75
Battery Management System (Option "Battery-Buffered Alarm System")75
Battery Present75
Charging Voltage76
Setting and Activating the Service Setpoint76
Setting the Service Setpoint76
Activating the Service Setpoint77
Co Emergency Cooling (Option)78
Connecting and Exchanging the Pressurized CO Cylinder79
Operating the CO Emergency Cooling System81
Settings on the Chamber Controller83
Setting the CO Emergency Cooling Temperature Setpoint83
Activating the CO Emergency Cooling83
Test Run of the CO Emergency Cooling84
Data Monitoring and Recording85
Ethernet Interface85
APT-COM™ 4 Multi Management Software (Option)85
Analog Output for Temperature (Option)85
Data Logger Kit (Option)85
Chamber Inventory: Storage Rack Systems and Cryo Boxes (Option)86
Storage Rack Systems with or Without Cryo Boxes86
Cryo Boxes86
Maintenance, Cleaning, and Service87
Maintenance Intervals, Service87
Service Reminder88
Cleaning and Decontamination88
Cleaning88
Decontamination90
Maintenance Work by the Customer92
Checking and Cleaning / Replacing the Condenser Air Filter92
Cleaning the Condenser93
Icing and Defrosting93
Sending the Chamber Back to BINDER Gmbh94
Disposal94
Disposal of the Transport Packing94
Decommissioning95
Disposal of the Chamber in the Federal Republic of Germany95
Disposal of the Chamber in the Member States of the EU Except for the Federal Republic of Germany96
Disposal of the Chamber in Non-Member States of the EU97
Troubleshooting98
Technical Description100
Factory Calibration and Adjustment100
Over Current Protection100
Battery Replacement (Option "Battery-Buffered Alarm System")100
Technical Data101
Equipment and Options (Extract)103
Optional Equipment, Accessories and Spare Parts (Extract)104
Dimensions UF V 500 (E3)106
Dimensions UF V 700 (E3)107
Certificates and Declarations of Conformity108
EU Declaration of Conformity108
Product Registration110
Contamination Clearance Certificate111
For Chambers Located Outside the USA and Canada111
For Chambers in the USA and Canada114

Binder UF V - Page 109

Table of Contents

Related product manuals