Danfoss vlt soft starter mcd 500 - Page 92

Features
Adaptive control... 8, 25, 36, 37, 38, 41, 57, 60, 61, 67, 68, 76,
81
Adaptive deceleration control....................................................... 8
Coast to stop..................................... 38, 39, 41, 51, 52, 61, 63, 67
DC brake.................................................................... 8, 39, 40, 47, 81
Emergency run................................................. 8, 45, 46, 59, 63, 70
In-line connection............... 8, 16, 18, 20, 21, 24, 51, 76, 78, 82
In-line installation.............................................................. 17, 18, 81
Inside delta......................................................................................... 78
Inside delta connection............ 8, 16, 22, 23, 24, 41, 76, 81, 82
Inside delta installation.................................................... 18, 19, 81
Internal bypass............................................................................. 8, 70
Jog............................................. 8, 40, 41, 51, 52, 59, 63, 70, 79, 81
Kick start.................................................................................. 8, 37, 59
Kick-start...................................................................................... 60, 67
Output signal simulation.......................................................... 8, 73
Output simulation........................................................................... 56
Protection simulation......................................................... 8, 56, 73
Soft brake.............................................................................................. 8
Soft braking
conguration........................................................... 48
Starter disable..................................... 8, 40, 47, 63, 64, 78, 79, 80
Thermal model............................ 8, 35, 39, 40, 56, 68, 69, 72, 74
Timed voltage ramp....................................... 8, 38, 41, 61, 67, 88
see also TVR
TVR........................................................................ 8, 38, 41, 61, 67, 88
see also Timed voltage ramp
FLC.... 16, 18, 24, 25, 30, 35, 37, 38, 54, 57, 60, 62, 65, 67, 76, 79,
80, 81, 88
see also Full load current
FLT....................................................................................................... 40, 88
see also Full load torque
Frequency trip....................................................................................... 62
Full load current...... 16, 18, 24, 25, 30, 35, 37, 38, 54, 57, 60, 62,
65, 67, 76, 79, 80, 81, 88
see also FLC
Full load torque.............................................................................. 40, 88
see also FLT
Fuses
British style (BS88)........................................................................... 27
Bussmann fuse.................................................................................. 26
European style (PSC 690).............................................................. 30
Ferraz...................................................................................... 28, 31, 32
Fuse................................................................................................ 17, 19
Fuse recommendation................................................................... 25
HRC fuse....................................................................................... 25, 82
HSJ......................................................................................................... 28
Motor branch circuit....................................................................... 39
Motor rated mains fuse.................................................................. 25
North American Style (PSC 690)................................................. 29
Power supply fuse............................................................................ 25
Protection fuse.................................................................................. 39
Semiconductor fuse................ 17, 18, 19, 25, 31, 32, 43, 44, 82
Short circuit rating............................................................. 30, 31, 32
Square body....................................................................................... 26
Type 1............................................................................................ 25, 82
Type 2............................................................................................ 25, 82
UL fuse selection.............................................................................. 30
G
Gain setting..................................................................................... 61, 68
General fault messages...................................................................... 81
H
Hand-on mode........................................................................ 51, 52, 53
Heat dissipation.................................................................................... 83
Heat sink................................................................................ 6, 59, 71, 77
Heat sink temperature.......................................................................... 8
I
Initial current.......................................................................................... 67
Input A trip......................................................................... 75, 77, 78, 79
Input rating............................................................................................. 82
Input trip............................................................................... 8, 46, 63, 64
Inputs
Control input..................................................................................... 16
Input A...... 40, 45, 46, 47, 48, 49, 50, 56, 59, 63, 64, 66, 71, 77,
78, 80, 81
Local control input............................................................................. 8
Power input........................................................................................ 15
Programmable input....... 33, 34, 40, 70, 73, 75, 77, 78, 79, 80,
82
Remote......................................................... 6, 13, 51, 52, 63, 66, 75
Remote control input................ 8, 33, 34, 43, 44, 45, 46, 48, 50
Reset.............................................................................................. 13, 64
Inside delta current....................................................................... 16, 18
Installation
Bypass contactor.............................................................................. 44
Clearance............................................................................................ 10
Derating values................................................................................. 10
Dimension.......................................................................................... 12
Externally bypassed................................................................. 17, 18
In-line installation.............................................................. 17, 18, 81
Inside delta installation.................................................... 18, 19, 81
Internally bypassed.................................................................. 17, 18
Main contactor.................................................................................. 43
Non-bypassed............................................................................ 17, 18
Side-by-side....................................................................................... 10
UL-compliant................................................................ 16, 83, 84, 85
Weight.................................................................................................. 12
Instantaneous overcurrent protection......................................... 62
K
Keys
Control keys......................................................................... 51, 52, 53
LCP keys............................................................................................... 63
Navigation keys................................................................................ 52
L
LCP...... 8, 13, 40, 51, 52, 53, 56, 58, 63, 66, 68, 69, 70, 73, 75, 81,
84, 86, 88
see also Local control panel
Local control............................................................... 14, 51, 52, 63, 80
Local control panel... 8, 13, 40, 51, 52, 53, 56, 58, 63, 66, 68, 69,
70, 73, 75, 81, 84, 86, 88
see also LCP
Index
VLT
®
Soft Starter MCD 500
90 Danfoss A/S © 05/2016 All rights reserved. MG17K602