Dodge ZB 2005 - Page 1418

TEST ACTION APPLICABILITY
3 WARNING: TURN IGNITION OFF, DISCONNECT THE BATTERYAND WAIT
TWO MINUTES BEFORE PROCEEDING.
Disconnect the Airbag Control Module connector
NOTE: Check connectors - Clean and repair as necessary.
WARNING: TURN THE IGNITION ON, THEN RECONNECT THE BATTERY.
Measure the voltage on the Driver SBS Line 1 and line 2 circuits at the Driver SBS
connector.
Is there any voltage present?
All
Yes → Repair the Driver Seat Belt Switch line 1 or line 2 shorted to
battery.
Perform AIRBAG VERIFICATION TEST - VER 1.
No → Replace theAirbag Control Module in accordance with the Service
information. WARNING: IF THE AIRBAG CONTROL MODULE
IS DROPPED AT ANY TIME, IT MUST BE REPLACED.
Perform AIRBAG VERIFICATION TEST - VER 1.
NOTE: When reconnecting Airbag system components, the ignition must be
turned off and the battery must be disconnected.
4 NOTE: Ensure the battery is fully charged.
With the DRBIIIt, record and erase all DTCs from all modules.
All active codes must be resolved before diagnosing any stored codes.
Maintain a safe distance from all airbags while performing the following steps.
With the DRBIIIt monitor active codes as you work through the system.
NOTE: If equipped with Passenger Airbag On-Off switch, read the DTC’s in
all switch positions.
Wiggle the wiring harness and connectors of the appropriate airbag system and
rotate the steering wheel from stop to stop.
NOTE: Check connectors - Clean and repair as necessary.
You have just attempted to simulate the condition that initially set the trouble code
message.
The following additional checks may assist you in identifying a possible intermittent
problem:
- Visually inspect related wire harness connectors. Look forbroken, bent, pushed out,
spread, corroded, or contaminated terminals.
- Visually inspect the related harnesses. Look forchafed, pierced, pinched or partially
broken wire.
- Refer to Wiring Diagrams and Technical Service Bulletins that may apply.
Did the DTC become active ?
All
Yes → Select appropriate symptom from Symptom List.
No → No problem found at this time. Erase all codes before returning
vehicle to customer.
37
AIRBAG
DRIVER SEAT BELT SWITCH SHORT TO BATTERY — Continued