Gehl 5625SX User Manual

C APTER 13
MAINTENANCE
This Maintenance Interval Chart was developed to match the Service Chapter of this manual. Detailed information on
each Service Procedure may be found in the Service Chapter. A Maintenance Log follows the Interval Chart for recording
the Maintenance Procedures performed. Recording the
10 Hour (or Daily) service intervals would be impractical and is
therefore not recommended.
NOTE: Under extreme operating conditions more frequent service than the recommended intervals
may
be required. You must decide if your actual operation requires more frequent service based on
your use.
MAINTENANCE INTERVAL CHART
Check Engine Air Cleaner SY~lC1l1_
Clean Radiator and Oil Cooler Fins
Every 100
Hours
Every 200
Hours
Check EI}giI!~_Oil Level _______ 1-- __
o
___ +- _____ -+- _____ -+ _____ -1
Check Hydraulic Oil Le~~L------------I--~--tl------t-------+-------I1
L~~~Lillh~~~T~~&C~i~qb~~_I ___ o ___ ~-----~------~-----~1
Check Seat & Restraint Bar OReratioIL __ ~ __ I ___ o ---1------+__-----+-------11
Check Bucket C)n!!ng Edge I 0
~~:~~ ;::~;::.:s~::rca;~-Oi~-~~~~I------~-----r-------!----+---0---+--------+--------11
Change Engine Oil and Filter 1 __ ~j-I ___ O __ ~i------~------iI
Clean SRark ArL~~l()I Muffler I I 0
I Check all Belt Tensions I 0 1------
1
--------11
,I Lubricate T-Bar Pivots----- --- ------;-~---------r-~-~;---l
II R t Wh IN t---------------- I---o---TI ------,--------11
I~ue ee us _____ -------~--~---------l-------f------+--------Ii
II Check Drive Chain Tension 1r-- __ o ___ +I _____ -1 _____ ---i1
Ii Check Chaincase oil-i~~--- I 0
I ------r-- 0 -~I-~
! Check BatterL~ ________________ [I--------I,------t-------+I--------11
~ge Hydraulic Filter Elemem _______________ ~____ _ _______ ~ ___ I ______ +__---o--__+--------II
Check Radiator Hoses~lIIc:I ~1<lillRL ______________ [__ +1 ______ -+ ___ o ___ t-- ____ ---II
1f--,-A""d:J-'ju""s,,-t ~P""ar"-'k"'in""'g'-'B""I"'"·a=-'ke"--_~_ --- - --- ---- - ---I--------------l----------+---o---+-------II
Grease Axle Bearinas'-____ -- I--~ I :
Retorque Enaine Mounts ..
~=~~==~==-----------------i------+--------l-------+------~'
i~ge Hydraulic OiU\I}~Lc::J~!Il~=tr=ai=n=eI~· -----t-------+- _____ -+- _____ -+ ___ O __ --il
II
I! Flush Radiator and ReRlace Anti-Freeze____ _i __ n __________ ~-----__+------+__--o---_II
I Chanae Fuel Filters ______ j 0
Chanae Chaincase Oil
--- _.~~ ___ ~l-._-.~- ___ -_-_- __ - __ - __ - __ -_- __ -JI~_~~_-~~ __ ~ _____ =h __ =o __ ==='J
NOTE: Continue to repeat the Service Procedures at every specified time interval.
78

Gehl 5625SX Specifications

General

Brand	Gehl
Model	5625SX
Category	Compact Loader
Language	English