Mar Cor Purification MILLENIUM HX - Page 7

3030226 Rev. D C ?
CHAPTER 5: ROUTINE MAINTENANCE ................................................................... 5-1
5.1 Routine Maintenance.................................................................................. 5-3
5.1.1 Per Treatment Day Maintenance ...................................................................... 5-4
5.1.2 Weekly Maintenance....................................................................................... 5-4
5.1.3 Monthly Maintenance ..................................................................................... 5-5
5.1.4 Quarterly Maintenance ................................................................................... 5-5
5.1.5 Annual Maintenance ....................................................................................... 5-6
5.1.6 As Required .................................................................................................... 5-6
5.2 Specific Maintenance Procedures and Instructions ....................................... 5-7
5.2.1 Leak Repair .................................................................................................... 5-7
5.2.2 Conductivity/Temperature Sensor Verification ................................................... 5-9
5.2.3 Membrane Replacement ............................................................................... 5-10
5.3 Cleaning Indications .................................................................................. 5-12
5.3.1 Cleaning Procedure ....................................................................................... 5-13
5.4 Chemical Sanitization Procedure ................................................................ 5-19
5.5 Product Water Microbiological Testing ...................................................... 5-25
5.5.1 Product Water Culture Procedure ................................................................... 5-25
5.5.2 Endotoxin Testing Procedure .......................................................................... 5-27
5.6 Chemical Storage Procedure ...................................................................... 5-28
5.7 Auto Run .................................................................................................. 5-30
CHAPTER 6: TROUBLESHOOTING ........................................................................... 6-1
6.1 RO Fails to Run ........................................................................................... 6-3
6.2 RO Feed Pressure Alarm .............................................................................. 6-3
6.3 Product Water Quality Alarm ...................................................................... 6-4
6.4 This Unit Must Stand Upright Alarm ............................................................. 6-4
6.5 Product Water High Temperature ................................................................ 6-5
6.6 RO Feed Water Quality Alarm ...................................................................... 6-5
6.7 Pump Pressure Alarm .................................................................................. 6-6
6.8 Product Pressure High Alarm ....................................................................... 6-6
6.9 Service Required Component Failure Detected ............................................. 6-7
6.10 Product Flow Too Low ............................................................................... 6-8
6.11 Product Flow Too High .............................................................................. 6-9
6.12 Leaks ........................................................................................................ 6-9