PREVOST H3-41 - Lubrication and Servicing Schedule

CARE AND MAINTENANCE
LUBRICATION AND SERVICING SCHEDULE
Caution: On new vehicles, preliminary servicing is required. Refer to the heading “First Service on New
Vehicle” in this chapter.
SERVICE EVERY 6,250 MILES (10 000 KM) OR TWICE A YEAR, WHICHEVER COMES FIRST
ITEM* DESCRIPTION REMARKS LUBRICANT
&/OR PART**
23 Engine air filter
Inspect and clean, replace
element if required.
Filter: #530197
24
Engine air pre-filter
Check discharge tube.
----------
22
A/C compressor
Check oil level, add if necessary.
Polyolester Oil
34 A/C receiver tank
Check refrigerant level, add if
necessary.
HFC 134a
33 Refrigerant moisture indicator
Replace filter dryer unit according
to moisture indicator (as needed).
Filter: #950262
11
Differential
Check oil level, add if necessary.
Multigrade gear oil
16 Radiator fan drive gearbox Check oil level, add if necessary.
Mobil SHC 630
#180217
31 Propeller shaft
Grease one fitting on each
universal joint and slip joint.
Multipurpose grease
12
Tag axle lever pivot
Grease one fitting on each pivot.
Multipurpose grease
4
Drag link ends
Grease one fitting at each end.
Multipurpose grease
6
Steering tie rod ends
Grease one fitting at each end.
Multipurpose grease
43
Steering Damper Cylinder
Grease one fitting at rod end.
Multipurpose grease
42
Steering Knuckle Pins
Grease two fittings per knuckle.
Multipurpose grease
--- Alternator Drive Belt Check for wear and cracks. -----------------------------
* Item numbers refer to figures on lubrication and servicing points in this chapter.
** See end of this section for lubricant and part number specifications.
107