PREVOST H3-41 - Page 116

CARE AND MAINTENANCE
SERVICE EVERY 100,000 MILES (160 000 KM) OR ONCE EVERY TWO YEARS, WHICHEVER COMES FIRST
ITEM* DESCRIPTION REMARKS
LUBRICANT
&/OR PART**
11 Differential Change oil; Clean breathers. Multigrade gear oil
3 Accessories air filter Change filter element. Filter: #641252
13
Eaton semiautomatic
transmission
Change oil
Eaton Roadranger CD
50 transmission fluid
32 Air dryer Change cartridge. Cartridge: #641278
--- Bosch T1 alternators
Change the brushes as per
“Repair and Testing Instructions
for T1 Alternator 0120 69 552”
annexed to section 06 of the
Maintenance Manual.
-------------
SERVICE EVERY 200,000 MILES (320 000 KM) OR ONCE EVERY FOUR YEARS, WHICHEVER COMES FIRST
ITEM* DESCRIPTION REMARKS
LUBRICANT
&/OR PART**
--- Bosch T1 alternators
Replace bearings as per “Repair
and Testing Instructions for T1
Alternator 0120 69 552” annexed
to section 06.
-------------
MISCELLANEOUS SERVICE
ITEM* DESCRIPTION REMARKS
LUBRICANT
&/OR PART**
15, 17 Cooling System
D
rain, flush and refill every two
years or 200,000 miles (320 000
km) whichever comes first.
Engine coolant
29 Battery Terminals Clean and coat terminals yearly.
Battery terminal
coating
--- Discharge Tubes***
Every three months:
Check 2 condenser's discharge
tubes;
Check 6 evaporator's discharge
tubes;
Check 2 front discharge tubes.
-------------
* Item numbers refer to figures on lubrication and servicing points in this chapter.
** See end of this section for lubricant and part number specifications.
*** Discharge tubes are rubber tubes located under vehicle.
109