Operation & Service Manual (VA) 106 ST1175
Mechanical hazards • 16
Monthly maintenance • 52
N
No control voltage • 69, 70, 72
No mains power • 69, 70, 72
O
Operating the pallet lifting mechanism • 47
Operation • 36, 37
OPERATION • 39
Operation of a single column • 46
OPTIONS • 75
Outdoor use • 49
P
Pair operation • 46
Pallet jack mechanism • 79, 90
Pallet lifting mechanism • 37
Pay attention to safety • 51
Personnel • 19
Power consumption • 29, 33
PREFACE • 6
Preparations before inspection and maintenance • 51
Preparations before operation • 47
Program 60 - Elevation limiter (code HS) • 58
Program 61 - Unlock while rising • 58
Program 62 - Protection against crushing • 58
Program 63 - Functional phase monitoring (code 04) • 58
Program 64 - CE-stop • 58
Program 65 - Safe limits • 59
Program 66 - Potentiometers OFF (check potentiometer
operation) • 59
Program 67 - Reading/calibrating potentiometers (code 16)
• 59
Programmable settings • 36, 57, 66, 67
R
Raising • 43
Raising and lowering • 48
REACH declaration • 31
Recommendations for maintenance • 51
Recommissioning • 13
Regular preventive maintenance procedures • 53
Removal and installation of the lifting cylinder • 62
Replacement parts • 63
Request for repair • 61
Required knowledge • 61
Retractable wheels • 37
Running procedures • 47
S
Safety • 49, 50, 52
SAFETY • 15
Safety features • 25
Safety instructions • 20
Safety signs • 25
Safety warnings • 18
Safety when hoisting • 39
Scope of this manual • 10
Setting the columns • 45
Slow lowering • 44
Spare parts • 61
Special adapters • 75, 95
Starting • 43
Statement of conformity • 14
Storing the manual • 12
Supplements to the manual • 12
T
Technical specifications • 33
Technical support • 9, 74
The column lift does not rise • 69
The column lift is not raising far enough • 71
The column lift lowers of its own accord • 71
The column lift will not lower • 70
The column lifts do not go up at the same speed • 72
The importance of safety • 18
The red (FAULT) push button indicator flashes when the
[UP] button is pressed • 73
Trademarks • 12
Training levels • 32
Troubleshooting • 53
TROUBLESHOOTING • 64
U
Unblocking in case of emergency • 49
Unpacking and setup • 38
V
Version history • 13
W
Waste disposal • 52
When you carry out maintenance • 50
Who is this manual intended for? • 10
Working in accordance with procedures • 18
To Next Page
